VehicleVerdict

2005 Airstream Classic problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 9 complaints on file for the 2005 Airstream Classic — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

9

NHTSA complaints

3

Recalls

0

Investigations

0

Crash-involved

0

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 2005 compare to other Classic years?

Classic NHTSA complaints by model year, 2005 highlighted9 complaints1995: 1 complaints2001: 0 complaints2002: 0 complaints2003: 1 complaints2004: 7 complaints2005: 9 complaints2006: 3 complaints2007: 1 complaints2008: 0 complaints2009: 0 complaints2014: 0 complaints2015: 0 complaints2016: 0 complaints2018: 0 complaints2019: 0 complaints2020: 0 complaints2021: 0 complaints2022: 0 complaints2023: 0 complaints2024: 0 complaints2025: 0 complaints2026: 0 complaints
Classic NHTSA complaints by model year, 2005 highlighted. Red bars are years to avoid.

See all Classic years to avoid →

What are the most common 2005 Airstream Classic problems?

ComponentComplaintsShare
Tires & Wheels333%
Brakes111%
Electrical System111%
Airbags111%
Body & Structure111%
Transmission111%
Engine111%

Does the 2005 Airstream Classic have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

10V344000BrakesJuly 22, 2010 · 737 units

Defect

AIRSTREAM IS RECALLING CERTAIN MODEL YEAR 2005-2009 CLASSIC TRAVEL TRAILERS MANUFACTURED FROM MARCH 2005 THROUGH APRIL 2009 AND EQUIPPED WITH HYDRAULIC BRAKE CONTROLLER BY ACTIVE TECHNOLOGIES. IT IS POSSIBLE THAT THE BRAKE CONTROLLER CAN FAIL UNEXPECTEDLY CAUSING THE BRAKES ON THE TRAILER TO LOCK UP OR TO FAIL COMPLETELY.

Consequence

THE LOCKING OF THE BRAKES OR BRAKE FAILURE COULD RESULT IN A LOSS OF VEHICLE CONTROL THAT COULD RESULT IN A CRASH AND POSSIBLE SERIOUS INJURY.

Remedy

DEALERS WILL INSPECT THE BRAKE CONTROLLER AND IF FOUND TO BE DEFECTIVE IT WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT AIRSTREAM AT 937-596-6111.

08V367000OtherJuly 21, 2008 · 4,450 units

Defect

AIRSTREAM IS RECALLING 4,450 MY 2004-2007 SAFARI, INTERNATIONAL, INTERSTATE, LAND YACHT, CLASSIC, MY 2004-2006 SKYDECK, AND MY 2006 PARKWAY TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy

AIRSTREAM IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR AIRSTREAM AT 1-937-596-6111.

04V506000SuspensionOctober 25, 2004 · 929 units

Defect

ON CERTAIN MOTORHOMES, THE OUTER WHEEL BEARING IN THE HUB OF THE AXLE MAY FAIL, LEADING TO UNEXPECTED SEPARATION OF THE WHEEL FROM THE AXLE. THIS FAILURE MAY BE DUE TO AN INADEQUATE AMOUNT OF GREASE IN THE HUB ASSEMBLY OR THE GREASE IN THE HUB MAY BREAK DOWN UNDER NORMAL OPERATING CONDITIONS INTO A LIQUID THAT INADEQUATELY LUBRICATES THE OUTER BEARING. INADEQUATE LUBRICATION OF THE OUTER BEARING CAN BEGIN A CHAIN OF EVENTS THAT COULD LEAD TO WHEEL SEPARATION.

Consequence

SEPARATION OF ONE OR MORE WHEELS FROM THE TRAILER COULD CAUSE THE TRAILER TO HANDLE ERRATICALLY OR GO OUT OF CONTROL. A LOST WHEEL COULD ALSO STRIKE AN ONCOMING OR FOLLOWING VEHICLE CAUSING A CRASH, RESULTING IN SERIOUS INJURY OF DEATH TO THOSE INVOLVED.

Remedy

DEALERS WILL REPAIR THE UNIT AND REMOVE THE WHEELS, INSPECT THE HUBS, INNER AND OUTER BEARINGS, RACES AND GREASE SEALS. IF NECESSARY, REPLACE PARTS AND REPACK THE WHEEL BEARING WITH HIGH TEMPERATURE GREASE AND REINSTALL THE HUB AND WHEELS. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT AIRSTREAM AT 1-877-596-6505.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“DT*: THE CONTACT STATED UPON INSPECTION OF THE TIRES BLISTERS WERE NOTICED ON THE SIDEWALLS OF ALL FOUR TIRES. THE DEALER HAS BEEN ALERTED”

Complaint filed with NHTSA · Tires & Wheels · April 19, 2006

“I HAVE SOME COMPLAINTS THAT THE DEALER IS INVESTIGATING. MY MAIN COMPLAINT IS THAT THERE ARE THOUSANDS OF COMPLAINTS LISTED FOR THIS MODEL AND POSSIBLY THIS YEAR ON ANOTHER WEBSITE THAT I ONLY FOUND OUT ABOUT AFTER RECENTLY BUYING MY VEHICLE. I HAVE POSTED A MESSAGE THERE ABOUT THIS SITE SO THAT…”

Complaint filed with NHTSA · Airbags · August 11, 2005

“DT: CONSUMER STATES THAT DUTCHMEN THOR PRODUCES A CAMPER, TAB, AND THEY HAVE AN ALCO BRAKE SYSTEM THAT THEY HAVE MODIFIED. THEY STATE IT HAS NOT BEEN MODIFIED. ACCORDING TO ALCO IN UNITED KINGDOM, THE COMPANY IS SETTING UP THE SYSTEM WRONG ON THE VEHICLE. WHEN HE TRIES TO GET INFORMATION FROM…”

Complaint filed with NHTSA · Brakes · May 2, 2005

“DT: THE CONSUMER STATES THAT THERE ARE MECHANICAL DIFFICULTIES WITH THE RV. DEALERSHIP TOLD CONSUMER TO CUT OUT THE CO2 DETECTION. CONSUMER STATES THERE IS A DEFECT IN THE UNIT. THERE IS NO GAS OR CO2 DETECTION IN IT. THE SENSORS HAVE BEEN DISCONNECTED BECAUSE THE ALARMS GO OFF, AND THEY WON'T FIX…”

Complaint filed with NHTSA · Engine · April 28, 2005

“DT: TWO CAR HAULER, MID AMERICA MFG., INC. ROUTE 1 BOX 875 BERTRAND, MO. 63823 CUSTOM BUILT TRAILER WHICH HAD VARIOUS SAFETY PROBLEMS SINCE DATE OF PURCHASE. POOR WELDING, TIRES, INAPPROPRIATE LIGHTING, HAND JACK WAS NOT EQUIPPED TO HANDLE WEIGHT LOAD. NO LICENCE PLATE HOLDER. UNDERSIZED WHEEL…”

Complaint filed with NHTSA · Body & Structure · April 18, 2005

2005 Airstream Classic — common questions

Is the 2005 Airstream Classic reliable?

The record is thin — 9 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.

Does the 2005 Airstream Classic have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2005 Airstream Classic. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.