Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 12 complaints on file for the 1990 Audi 80 — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
12
NHTSA complaints
3
Recalls
2
Investigations
2
Crash-involved
0
Fires reported
2
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Transmission | 8 | 67% | — flat |
| Electrical System | 2 | 17% | new |
| Airbags | 1 | 8% | new |
| Fuel System | 1 | 8% | new |
3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME AIR BAG SENSORS DO NOT COMPLY WITH AUDI'S DURABILITY STANDARDS OVER THE LIFETIME OF THE VEHICLE.
Consequence
IN THE EVENT THE SENSOR SHOULD MALFUNCTION, THE AIR BAG RESTRAINT SYSTEM CAN INADVERTENTLY DEPLOY. DEPLOYMENT OF THE AIR BAG RESTRAINT SYSTEM WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL.
Remedy
DEALERS WILL REPLACE THE AIR BAG SENSOR CONTROL MODULE.
Defect
THE DIFFERENTIAL OIL OF THE TRANSAXLE IS LOST OVER TIME DUE TO EVAPORATION. LOW OIL LEVELS CAUSE PREMATURE BEARING AND GEAR WEAR AND EVENTUAL FAILURE OF THE DIFFERENTIAL.
Consequence
IN THE EVENT OF FAILURE, THE VEHICLE'S DRIVE WHEELS COULDLOSE POWER. IN EXTREME CIRCUMSTANCES, THE FRONT WHEELS LOCK, CAUSING RAPIDDECELERATION RESULTING IN POSSIBLE LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy
DRAIN AND REPLACE THE DIFFERENTIAL GEAR OIL WITH OIL HAVING HIGHER PERFORMANCE CHARACTERISTICS.
Defect
IMPROPERLY MANUFACTURED STEERING LOCK BOLTS COULD BREAK IF DRIVER APPLIES EXCESSIVE FORCE TO A LOCKED STEERING WHEEL IN AN ATTEMPT TO DISENGAGE THE STEERING LOCK.
Consequence
BOLT BREAKAGE WOULD CAUSE STEERING WHEEL TO REMAIN LOCKED EVEN AFTER THE DRIVER TURNS THE IGNITION KEY AND ATTEMPTS TO MOVE THE CAR; THIS TOTAL LOSS OF STEERING CONTROL COULD RESULT IN AN ACCIDENT.
Remedy
REPLACE COMPLETE STEERING LOCK ASSEMBLY, INCLUDING A MODIFIED LOCK BOLT.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“THE DIFFERENTIAL FAILURE WAS DUR TO "LACK OF OIL IN THE CHAMBER" THE VEHICLE STILL HAD THE ORIGINAL COMPONENT AND THE RECORD KEPT BY THE ORIGINAL OWNER INDICATE THAT NO DIFFERENTIAL RECALL WORK WAS DONE ON THIS VEHICLE. I CONTACT AUDI OF AMERICA'S NATION CONSUMER OFFICE AND THEY SAID THERE WAS NO…”
“THE BATTERY DIED, CALLED AAA AND HAD THE BATTERY RECHARGED. THEN TURNED THE IGNITION ON AND THE DRIVER'S SIDE AIRBAG DEPLOYED, AND THREW THE CONSUMER MORE THAN 5 FEET AWAY INTO A BRICK WALL. *AK THE AIR BAG WAS DEPLOYED WHILE JUMP STARTING THE VEHICLE. AS THE RESULT OF AIR BAG DEPLOYING, ELECTRICAL…”
“THE BATTERY DIED, CALLED AAA AND HAD THE BATTERY RECHARGED. THEN TURNED THE IGNITION ON AND THE DRIVER'S SIDE AIRBAG DEPLOYED, AND THREW THE CONSUMER MORE THAN 5 FEET AWAY INTO A BRICK WALL. *AK THE AIR BAG WAS DEPLOYED WHILE JUMP STARTING THE VEHICLE. AS THE RESULT OF AIR BAG DEPLOYING, ELECTRICAL…”
“CONSUMER NOTICED DRIPPING OF GAS TANK. VEHICLE WAS TAKEN TO DEALER WHO STATED THAT LEAK CAUSED BY RUST AT TOP OF FUEL TANK.*AK”
The record is thin — 12 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.
According to NHTSA complaint data, the leading problem areas are transmission (8 complaints), electrical system (2 complaints), airbags (1 complaints).
Yes — NHTSA lists 3 recall campaigns affecting the 1990 Audi 80. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
NHTSA opened 2 investigations into this model year; all are now closed.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.