2019 E-One Quest Ii problems

Defect

E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2, Quest 2, 2020-2021 Typhoon N, 2020 Typhoon, and 2021 Cyclone N vehicles. The fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak.

Consequence

A high pressure fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy

Dealers will replace the fuel tubes and install vibration isolators, free of charge. Owner notification letters were mailed February 14, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Defect

E-One Incorporated (E-One) is recalling certain 2017-2021 Cyclone 2, Cyclone N, Quest 2, Typhoon, and Typhoon N vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Consequence

A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will inspect and replace the rail as necessary, free of charge. Owner notification letters were mailed out on May 28, 2021. Owners may contact E-One customer service at 1-352-237-1122.

Defect

E-One Incorporated (E-One) is recalling certain 2013-2019 Typhoon and Cyclone 2, 2013-2014 Cyclone 3, 2014-2019 Quest 2 and 2017 CHSH emergency vehicles equipped with a Cummins ISL, L9, ISX12, X12, ISX15, or X15 engine. The engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.

Consequence

The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies, increasing the risk of an injury.

Remedy

E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began November 15, 2019. Owners may contact E-One customer service at 1-352-861-3612. Note: Vehicles previously repaired under recall 18V-019 also need this recall remedy.

Defect

E-One Incorporated (E-One) is recalling certain 2017-2019 Cyclone II, Typhoon and Quest II emergency vehicles, equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy

E-One will notify owners, and dealers will replace the brake lights, free of charge. The recall began October 26, 2018. Owners may contact E-One customer service at 1-352-861-3612.