Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 0 complaints on file for the 1980 Flxible Transit Coach — too few to judge reliability from owner reports alone — but 5 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
0
NHTSA complaints
5
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
5 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
THE SET-SCREW MAY NOT BE POSITIONED CORRECTLY, ALLOWING THE DRIVE KEY TO SLIDE OUT OF THE HUB AND THE HUB AND SPROCKET TO DISENGAGE. THIS WOULD CAUSE THE WHEELCHAIR PLATFORM TO FALL TO THE GROUND WITHOUT PRIOR WARNING.
Remedy
WHEELCHAIR LIFT WILL BE INSPECTED FOR THE CORRECT POSITIONING OF THE SET-SCREW. IF NECESSARY, THE DRIVE KEY WILL BE TACK WELDED INTO THE DRIVE HEX WITHOUT CHARGE.
Defect
CRACKS MAY DEVELOP IN THE TRUNNION TO WHICH THE APEX OF THE "A-FRAME" IS ATTACHED. THESE CRACKS MAY PROGRESS TO THE POINT THAT THE TRUNNION COULD FAIL AND THE A-FRAME COULD SEPARATE FROM IT. IF THIS OCCURS, THE A-FRAME COULD COME INTO CONTACT WITH THE CONDUIT CARRYING AIR, AS WELL AS THE ELECTRICAL AND FUEL LINES.
Remedy
TRUNNION WILL BE INSPECTED FOR CRACKS AND, IF POSSIBLE, CRACKS WILL BE REPAIRED AS AN INTERIM MEASURE. ALL TRUNNIONS WILL BE REINFORCED BY GRUMMAN; ANY DEFORMED TRUNNIONS WILL BE REPLACED WITH A REINFORCED PART. REPAIRS WILL BE PERFORMED AT NO CHARGE.
Defect
THE POWER CABLES LEADING FROM THE BATTERIES OF THE INVOLVED VEHICLES ARE SUBJECT TO A CHAFING CONDITION, WHICH, IF UNDETECTED OR NOT CORRECTED CAN CAUSE WEAR TO THE CABLE INSULATION.
Remedy
TO PREVENT CHAFING OF THE BATTERY CABLES, THE DEALER WILL INSTALL FOUR BATTERY CLAMPS, TWO EACH ON THE BATTERY HOLD DOWN BAR AND THE FUEL BOLSTER BRACKET, AND INSTALL PIECES OF RUBBER HOSE INSULATION ONTO THE LARGER POWER CABLES. THIS WILL BE DONE AT NO EXPENSE TO OWNER.
Defect
ON CERTAIN VEHICLES, THE DRIVER"S BARRIER GLAZING WAS NOT MARKED AS SAFETY GLAZING MATERIAL. THIS DOES NOT MEET THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS".
Remedy
FIELD SERVICE REPRESENTATIVES WILL INSTALL THE CORRECT DECALS AT NO CHARGE TO OWNERS.
Defect
THE CHAIN DRIVE WELDMENT MAY FAIL UNDER A LIFT LOAD ALLOWING THE WHEELCHAIR PLATFORM TO FALL TO THE GROUND. ALSO, THE TOP KNUCKLE JOINT WELDMENT MAY CONTAIN DEFECTIVE WELDS.
Remedy
MANUFACTURER WILL PROVIDE THE PARTS NECESSARY TO REPAIR WHEELCHAIR LIFTS AND WILL REIMBURSE FOR LABOR COSTS.
The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 5 recalls should be verified as completed.
Yes — NHTSA lists 5 recall campaigns affecting the 1980 Flxible Transit Coach. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.