Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 4 complaints on file for the 1990 Ford E-250 — too few to judge reliability from owner reports alone — but 2 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
4
NHTSA complaints
2
Recalls
6
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Fuel System | 2 | 50% | — flat |
| Engine | 1 | 25% | — flat |
| Speed Control | 1 | 25% | new |
2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
Consequence
THE OVERFLOW OF FUEL PAST THE FILLER CAP CAUSES A FUELLEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy
REPLACE THE DUAL FUEL TANK SELECTOR VALVE.
Defect
UNDER CERTAIN CONDITIONS, THE SNAP RING THAT LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE.
Consequence
WHEN THE GEAR IS PLACED IN PARK, THE PARK GEAR WOULD NOTENGAGE, ALLOWING THE TRUCK TO ROLL FREELY IF THE PARKING BRAKE IS NOT PROPERLYSET. THIS COULD RESULT IN AN ACCIDENT.
Remedy
INSTALL IMPROVED SNAP RING AND REVISED TRANSMISSION EXTENSION HOUSING.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“CAN'T SWITCH FROM FRONT AUX. GAS TANK TO REAR MAIN GAS TANK, AND GAS GAUGE NOT FUNCTIONING. VERY SLOW FILLING AND NOTICED GAS COMING OUT OF FILLER SPOUT. THIS VAN IS NEW TO ME AND JUST NOTICED THESE PROBLEMS THIS MONTH MAY 1/2017”
“ON (2) OCCASIONS, TRUCK WILL ACCELERATE 40 TO 50 MPH MORE UNWANTED. DRIVER REACH TO PULL ACCELERATOR WITH NO CHANGE IN CONDITION. PLEASE DESCRIBE DETAILS. TT”
The record is thin — 4 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 2 recalls should be verified as completed.
Yes — NHTSA lists 2 recall campaigns affecting the 1990 Ford E-250. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
NHTSA opened 6 investigations into this model year; all are now closed.
Based on complaint rates and open investigations, the E-250 years to avoid are 1999, 1997, 1998, 1992. The cleanest record among E-250 years belongs to 2023.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.