2022 Ford F-150 Lightning Bev electrical system problems

Defect

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles previously repaired incorrectly under recall number 23V801. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence

Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.

Remedy

Dealers will update the Accessory Protocol Interface Module (APIM) software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C15.

Defect

Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.

Consequence

Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.

Remedy

Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 21, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S11. This recall expands previous recall number 24V-144.

Defect

Ford Motor Company (Ford) is recalling certain 2022-2024 F-150 Lightning battery electric vehicles. A manufacturing defect in the high voltage battery cells may result in an internal short circuit.

Consequence

A battery short circuit increases the risk of a fire.

Remedy

Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will inspect and replace the high voltage battery array as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.

Defect

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence

Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.

Remedy

The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C38.