2000 Ford Taurus lighting problems

Defect

CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.

Consequence

IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.

Remedy

DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Defect

VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. DUE TO THE USE OF INCORRECT MATERIAL BY A SUPPLIER, THE HEADLAMP SWITCH KNOB CAN FRACTURE AND SEPARATE FROM THE HEADLAMP SWITCH.

Consequence

THIS WOULD CAUSE DIFFICULTY FOR THE DRIVER TO ACTIVATE THE HEADLAMPS, WHICH COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE HEADLAMP SWITCH KNOB. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.

Consequence

A SHORT CIRCUIT COULD LEAD TO EITHER THE BRAKE LAMPS STAYING ON, OR TO A LOSS OF BRAKE LAMP FUNCTION, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE BRAKE LAMP SWITCH AND WIPE DOWN THE ADJUSTABLE PEDAL ASSEMBLY TO REMOVE EXCESS GREASE. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Defect

VEHICLE DESCRIPTION: PASSENGER SEDANS WITH FACTORY OR DEALER-INSTALLED DECK LID SPOILERS WITH LED CENTER HIGH MOUNTED STOP LAMPS (CHMSL). VEHICLES PRODUCED WITH SPOILERS WERE MANUFACTURED FROM MARCH 1 THROUGH OCTOBER 31, 2000; AND VEHICLES WITH SPOILERS INSTALLED BY DEALERS WERE MANUFACTURED FROM JANUARY 1 THOROUGH DECEMBER 30, 2000. WITH THE IGNITION SWITCH IN THE START OR RUN POSITIONS AND THE HAZARD WARNING LIGHTS OPERATING, THE CHMSL CAN ILLUMINATE (AT REDUCED INTENSITY) EVEN THOUGH THE SERVICE BRAKES HAVE NOT BEEN APPLIED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ALSO, IN SOME CASES THE VEHICLE BRAKE-SHIFT INTERLOCK WOULD NOT FUNCTION PROPERLY, ALLOWING THE SHIFT LEVER TO BE MOVED FROM PARK WITHOUT APPLYING THE BRAKE.

Consequence

UNDER THE REQUIREMENTS OF THE STANDARD, THE CHMSL SHALL BE ACTIVATED ONLY UPON APPPLICATION OF THE SERVICE BRAKES. ALSO, THE VEHICLE COULD ROLL INCREASING THE RISK OF A CRASH, IF THE SHIFT LEVER CAN BE SHIFTED OUT OF PARK WITHOUT DEPRESSING THE BRAKE PEDAL.

Remedy

DEALERS WILL INSTALL A JUMPER/RESISTOR ASSEMBLY AT THE SPOILER THAT PROVIDES AN ELECTRICAL RESISTOR TO GROUND AND CORRECTS THE CHMSL AND BRAKE-SHIFT INTERLOCK CONDITIONS. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.