Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just one complaint on file for the 1997 Freightliner FL80 — too few to judge reliability from owner reports alone — but one recall campaign applies to this year, so any used example should have its VIN checked for completed recall work.
1
NHTSA complaints
1
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Steering | 1 | 100% | new |
1 NHTSA recall campaign on file. Recall repairs are free at franchised dealers.
Defect
VEHICLE DESCRIPTION: HEADY DUTY TRUCKS EQUIPPED WITH 36" REAR BRAKE CHAMBERS. THE BRAKE SYSTEM DOES NOT MEET THE AIR RESERVOIR VOLUME REQUIREMENT OF FMVSS 121, "AIR BRAKE SYSTEMS."
Consequence
INCREASED BRAKING DISTANCE CAN OCCUR INCREASING THE RISK OF A VEHICLE CRASH.
Remedy
DEALERS WILL REPAIR THESE VEHICLES.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“PROBLEM: BALL STUD & SOCKET ASSEMBLY SEPARATED. REVIEW NHTSA #OOV-246.001 TRUCK: 1997 FREIGHTLINER, FL-80 - SERIAL # [XXX] IN-SERVICE DATE: MAY 9, 1997 - MILEAGE 76,389 THE STATE OF CONNECTICUT, DEPT. OF TRANS., HAS A LARGE NUMBER OF 1997 THRU 1999 FREIGHTLINER, FL-80 DUMP TRUCKS, USED FOR SNOW AND…”
The record is thin — 1 NHTSA complaint — so owner-report data can't strongly confirm reliability either way, though 1 recall should be verified as completed.
Yes — NHTSA lists 1 recall campaign affecting the 1997 Freightliner FL80. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.