1993 Freightliner Fla problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 0 complaints on file for the 1993 Freightliner Fla — too few to judge reliability from owner reports alone — but 5 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

NHTSA complaints

Recalls

Investigations

Crash-involved

Fires reported

Injuries

Deaths

—

NCAP overall

How does 1993 compare to other Fla years?

Fla NHTSA complaints by model year, 1993 highlighted. Red bars are years to avoid.

See all Fla years to avoid →

Does the 1993 Freightliner Fla have recalls?

5 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

97V114001LightingAugust 4, 1997 · 77,000 units

Defect

VEHICLE DESCRIPTION: HEAVY DUTY TRUCK. THE SHOULDER BOLT WHICH HOLDS THE GROTE TURN SIGNAL SWITCH CASE AND COMPONENTS TOGETHER CAN LOOSEN RESULTING IN THE TURN SIGNAL MALFUNCTIONING.

Consequence

IF THE TURN SIGNAL FUNCTION IS LOST, FOLLOWING MOTORISTS WOULD NOT BE AWARE OF THE TURNING VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy

DEALERS WILL INSPECT THESE VEHICLES AND TIGHTEN ANY LOOSE BOLTS AND IN THE TURN SIGNAL SWITCH WITHIN 2 YEARS FROM THE DATE OF THE RECALL NOTIFICATION LETTER. THE SHOULDER BOLT WILL BE REMOVED, CLEANED, AND REINSTALLED WITH LOCTITE. OWNERS CAN ALSO REQUEST LOCTITE AND REPAIR INSTRUCTIONS SO THEY CAN FIX THE VEHICLES THEMSELVES.

96V232000EngineNovember 13, 1996 · 27,500 units

Defect

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HORTON FAN DRIVES. THE FAN DRIVE CONTROL SYSTEM WAS RECONFIGURED WHICH RESULTED IN A SIGNIFICANT INCREASE IN THE DEMAND FOR FAN ACTIVATION AND ASSOCIATED STRESS TO ELECTRICAL AND MECHANICAL COMPONENTS. VARIOUS COMPONENT FAILURE MODELS, COMBINED WITH CHARACTERISTICS OF THE FAN CLUTCH AND ITS BEARINGS, CAN CAUSE FAN CLUTCH BEARINGS TO FAIL PREMATURELY AND RESULT IN A LOCKED FAN.

Consequence

IF THE FAN IS LOCKED, THE THE SYSTEM CALLS FOR THE FAN TO BE ON, THE FAN CLUTCH WILL SLIP, GENERATE HEAT, AND UNLESS RELEASED, WILL RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE FAN CLUTCH DRIVE DISC WITH ONE THAT INCORPORATES A THERMALLY ACTIVATED PRESSURE RELIEF.

95E003005BrakesApril 3, 1995 · 18,500 units

Defect

AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVER PRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.

Consequence

IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGECAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.

Remedy

DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.

93V202000TransmissionDecember 6, 1993 · 11,000 units

Defect

THE DRIVELINE U-JOINTS EXHIBIT EXCESSIVE RATES OF FAILURE AT LOW MILEAGES AND MAY CAUSE SEPARATION OF THE INTERAXLE DRIVELINE.

Consequence

SEPARATION OF THE INTERAXLE DRIVELINE MAY RESULT IN THEDRIVELINE FALLING TO THE ROAD WHERE IT CAN INTERFERE WITH TRAFFIC AND RESULTIN AN ACCIDENT.

Remedy

FREIGHTLINER DEALERS WILL REMOVE AND REPLACE THE ROCKWELL INTERAXLE U-JOINTS WITH U-JOINTS OF A DIFFERENT DESIGN.

93V149000Visibility & WipersSeptember 14, 1993 · 505 units

Defect

CONTACT INTERFERENCE BETWEEN THE WINDSHIELD WIPER LINKAGE AND THE MOTOR OUTPUT SHAFT NUT CAUSES LINKAGE SEPARATION, RESULTING IN FAILURE OF THE SYSTEM.

Consequence

FAILURE OF THE WINDSHIELD WIPER SYSTEM REDUCES DRIVERVISIBILITY IN INCLEMENT WEATHER WHICH COULD RESULT IN AN ACCIDENT.

Remedy

REMOVE AND REPLACE THE WINDSHIELD WIPER LINKAGE WITH A REDESIGNED LINKAGE THAT PROVIDES ADDITIONAL CLEARANCE WITH THE WIPER MOTOR OUTPUT SHAFT.

1993 Freightliner Fla — common questions

Is the 1993 Freightliner Fla reliable?

The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 5 recalls should be verified as completed.

Does the 1993 Freightliner Fla have recalls?

Yes — NHTSA lists 5 recall campaigns affecting the 1993 Freightliner Fla. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.

How does 1993 compare to other Fla years?

Does the 1993 Freightliner Fla have recalls?

1993 Freightliner Fla — common questions

Is the 1993 Freightliner Fla reliable?

Does the 1993 Freightliner Fla have recalls?

Related