Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just one complaint on file for the 1999 Harley-Davidson Fltri — too few to judge reliability from owner reports alone — but 2 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
1
NHTSA complaints
2
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Engine | 1 | 100% | — flat |
2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
ON CERTAIN TOURING AND POLICE MODEL MOTORCYCLES, THE 40 AMP MAIN CIRCUIT BREAKER CAN "OPEN" FOR REASONS OTHER THAN WHICH IT WAS DESIGNED, CAUSING AN UNEXPECTED INTERRUPTION OF ALL ELECTRICAL POWER TO THE MOTORCYCLE.
Consequence
THIS CONDITION COULD CAUSE THE MOTORCYCLE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL REPLACE THE CIRCUIT BREAKER. OWNER NOTIFICATION BEGAN APRIL 23, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Defect
VEHICLE DESCRIPTION: MOTORCYCLES. THE ENGINE CAM BOLT CAN LOSE ITS CLAMP LOAD AND/OR BREAK.
Consequence
THIS CONDITION CAN CAUSE THE ENGINE TO QUIT RUNNING WITH OR WITHOUT PRIOR WARNING. IN SOME INSTANCES, THE ENGINE COULD RUN ERRATICALLY BEFORE QUITTING.
Remedy
DEALERS WILL REPLACE THE ENGINE CAM BOLTS AND WASHERS.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“THERE HAVE BEEN NUMEROUS FAILURES OF THE ENGINE CAM BEARINGS IN 1999 TWIN CAM MOTORS WHICH IS A NEW DESIGN FROM HARLEY DAVIDSON. HARLEY DAVIDSON HAS SINCE REPLACED THE DEFECTIVE BEARINGS WITH A STRONGER ONE, HOWEVER, THE REFUSE TO RECALL MOTORS WITH THE BAD BEARINGS IN THEM UNLESS THE CUSTOMER PAYS…”
The record is thin — 1 NHTSA complaint — so owner-report data can't strongly confirm reliability either way, though 2 recalls should be verified as completed.
Yes — NHTSA lists 2 recall campaigns affecting the 1999 Harley-Davidson Fltri. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.