Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 7 complaints on file for the 2008 Harley-Davidson Fxdl — too few to judge reliability from owner reports alone — but one recall campaign applies to this year, so any used example should have its VIN checked for completed recall work.
7
NHTSA complaints
1
Recalls
1
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Fuel System | 3 | 43% | ▲ up |
| Electrical System | 2 | 29% | ▲ up |
| Engine | 1 | 14% | — flat |
| Suspension | 1 | 14% | — flat |
1 NHTSA recall campaign on file. Recall repairs are free at franchised dealers.
Defect
ON CERTAIN MOTORCYCLES BUILT AND SHIPPED TO CALIFORNIA, THE CATALYTIC MUFFLER PROTECTIVE HEAT SHIELD WAS NOT INSTALLED. THIS CONDITION COULD ALLOW DIRECT CONTACT WITH THIS MUFFLER AND CAUSE INJURY.
Consequence
IF CONTACT OCCURS WHILE RIDING, IT COULD CAUSE LOSS OF CONTROL OF THE MOTORCYCLE, LEADING TO INJURY OR DEATH.
Remedy
DEALERS WILL INSTALL THE HEAT SHIELDS TO THE MUFFLERS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 26, 2007. OWNERS MAY CONTACT HARLEY DAVIDSON AT 1-414-343-4056.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“APPROACHING A RED LIGHT, GEARING DOWN TO STOP, THE IDLE CONTINUED ABOVE 3000RPM. SHORTLY AFTER THAT, THE BIKE STARTED EATING THE BATTERY. NOW, WHEN IT HAPPENS, I KNOW TO GET IT HOME TO THE BATTERY TENDER ASAP. THREE TIMES THE HD MECHANICS CHARGE THE BATTERY AND THEN, "CAN'T FIND ANYTHING WRONG". I…”
“APPROACHING A RED LIGHT, GEARING DOWN TO STOP, THE IDLE CONTINUED ABOVE 3000RPM. SHORTLY AFTER THAT, THE BIKE STARTED EATING THE BATTERY. NOW, WHEN IT HAPPENS, I KNOW TO GET IT HOME TO THE BATTERY TENDER ASAP. THREE TIMES THE HD MECHANICS CHARGE THE BATTERY AND THEN, "CAN'T FIND ANYTHING WRONG". I…”
“UNCONTROLLABLE IDLE, HARLEY DAVIDSON FLY BY WIRE THROTTLE. IDLE INTERMITTENTLY WILL GO ABOVE 1800 RPM. A FACTORY KNOWN ISSUE WITH NO PERMANENT REPAIR OR REPLACEMENT. I JUST BOUGHT A NEW HARLEY AND HAVE EXPERIENCED THIS 2 TIMES BOTH TIMES THE DEALER EXPERIENCED THE PROBLEM AS WELL..SAID IT WAS FIXED…”
“TL* THE CONTACT OWNS A 2008 HARLEY DAVIDSON FXDL. WHILE DRIVING 55 MPH, THE CONTACT STATED THAT THE WHEEL BEARING SEPARATED FROM THE VEHICLE. THE DEALER REPAIRED THE WHEEL, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 13,000 AND THE CURRENT…”
The record is thin — 7 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 1 recall should be verified as completed.
Yes — NHTSA lists 1 recall campaign affecting the 2008 Harley-Davidson Fxdl. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
NHTSA opened one investigation into this model year; all are now closed.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.