Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just one complaint on file for the 2007 Harley-Davidson XL883R — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
1
NHTSA complaints
3
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Transmission | 1 | 100% | new |
3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
CERTAIN MOTORCYCLES WERE BUILT WITH A CONDITION WHEREBY THE PANT LEG OF SOME RIDERS CAN HAVE DIRECT CONTACT WITH THE EXHAUST PIPE.
Consequence
THIS CONDITION COULD CAUSE THE PANT LEG TO CHAR OR BURN, WHICH COULD LEAD TO THE POSSIBILITY OF INJURY TO THE RIDER.
Remedy
DEALERS WILL ADD A NEW EXHAUST SHIELD WHICH PROVIDES ADDITIONAL COVERAGE OFTHE EXHAUST PIPE. THE RECALL BEGAN ON JULY 12, 2007. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Defect
CERTAIN SPORTSTER AND DYNA MODEL MOTORCYCLES WERE BUILT WITH AN INCORRECT FRONT TIRE.
Consequence
THIS INCORRECT TIRE COULD CAUSE PERFORMANCE ISSUES, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL INSPECT THE FRONT TIRE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Defect
ON CERTAIN MOTORCYCLES, AS A RESULT OF A GREATER BODY THICKNESS THAN USED IN PREVIOUS MODEL YEARS, THE VOLTAGE REGULATOR MAY CONTACT THE FRONT FENDER UNDER CERTAIN CONDITIONS. IN SOME CASES THIS CONTACT MAY ALLOW THE FRONT FENDER TO CATCH ON THE TOP SIDE OF THE REGULATOR BODY WHICH COULD IMPEDE THE OPERATOR'S ABILITY TO STEER THE VEHICLE.
Consequence
THIS COULD RESULT IN A CRASH WHICH COULD CAUSE INJURY OR DEATH TO THE RIDER.
Remedy
ON MOTORCYCLES WHICH DO NOT HAVE ACCESSORY ENGINE GUARDS, DEALERS WILL INSTALL AN INTERMEDIATE MOUNTING BRACKET THAT WILL RELOCATE THE VOLTAGE REGULATOR TO A POSITION WHICH PROVIDES MORE CLEARANCE FROM THE FRONT FENDER. ON VEHICLES WITH AN ACCESSORY ENGINE GUARDS, DEALERS WILL INSTALL THE THINNNER DIMENSION VOLTAGE REGULATOR TO AVOIDE THE FRONT FENDER CLEARANCE PROBLEM. THE RECALL BEGAN ON JANUARY 22, 2007. A SECOND CUSTOMER LETTER REFLECTING THE ABOVE REMEDY WILL BE SENT TO OWNERS ON MARCH 16, 2007. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“THE COMPENSATOR SPROCKET BEGAN TO THUMP AND KNOCK ON CURBSIDE STARTING, INDICATING WEAR. IT ONLY HAPPENS WITH THE BIKE IN GEAR AND THE CLUTCH DEPRESSED. IT DOES NOT HAPPEN IN NEUTRAL. IT CLEARED UP WITHIN 30 MINUTES, AND I CHANGED THE GEAR OIL, HOWEVER NOW I AM AFRAID TO DRIVE IT BECAUSE IF IT GOES…”
The record is thin — 1 NHTSA complaint — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.
Yes — NHTSA lists 3 recall campaigns affecting the 2007 Harley-Davidson XL883R. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.