Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 4 complaints on file for the 1995 Jayco Designer — too few to judge reliability from owner reports alone — but 2 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
4
NHTSA complaints
2
Recalls
0
Investigations
0
Crash-involved
2
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Electrical System | 1 | 25% | new |
| Other | 1 | 25% | new |
| Body & Structure | 1 | 25% | new |
| Tires & Wheels | 1 | 25% | new |
2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence
OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.
Remedy
FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.
Defect
STAPLES WERE USED TO FASTEN THE STEP BOX ON THE REAR CORNERS INSTEAD OF SCREWS.
Consequence
THE WEIGHT OF A PERSON STEPPING ONTO THE STEP BOX COULD CAUSE THE STEP TO BREAK LOOSE AND POSSIBLY CAUSE PERSONAL INJURY.
Remedy
DEALERS WILL INSTALL A SUPPORT KIT WHICH CONSISTS OF TWO ANGLED BRACKETS AND ADDITIONAL SCREWS TO SUPPORT THE STEP BOX.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“THREE TIRES HAD BLOWN OUT IN THE LAST YEAR. THE MOST RECENT BLOW OUT WAS ON 7/04/2003. FRONT AND REAR DRIVER SIDE TIRE BLEW OUT WHILE DRIVING DUE TO TREAD SEPARATION. *AK *PH *JB”
“MY NAME IS BILL COMPTON AND I AM A DEPUTY WITH THE KENTUCKY FIRE MARSHAL'S OFFICE. I WAS DISPATCHED TO INVESTIGATE THE CIRCUMSTANCES SURROUNDING A FIRE IN A 5TH WHEEL CAMPER. THE 5TH WHEEL CAMPER WAS JAYCO DESIGNER SERIES PRODUCED ON 4-21-95 WITH A VIN# INDICATIONS ARE THE FIRE STARTED IN THE…”
“MY NAME [XXX] I AM A FIRE FIGHTER WITH MENDON FIRE DEPARTMENT WE HAD A FIRE ON 09/12/2015 DO TO REFRIGERATOR NORCOLD ACCORDING TO THE FIREMARSHAL'S INVESTIGATION. WE JUST BOUGHT THE TRAILER 08/27/2015 AND ON THE NIGHT OF 09/12/2015 ABOUT 1 AM I WOKE UP AND LOOKED OUT THEWINDOW NOTICING A GLOWING IT…”
“THE 5TH WHEEL TRAILER EXTERIOR FIBERGLASS SIDINGS ARE COMING APART WHERE THE SIDING MAY FALL OFF WHICH MAY CAUSE AN ACCIDENT. DEALER CANNOT DETERMINE PROBLEM. *AK”
The record is thin — 4 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 2 recalls should be verified as completed.
Yes — NHTSA lists 2 recall campaigns affecting the 1995 Jayco Designer. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.