VehicleVerdict

1996 Kenworth T600 problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 0 complaints on file for the 1996 Kenworth T600 — too few to judge reliability from owner reports alone — but 5 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

0

NHTSA complaints

5

Recalls

0

Investigations

0

Crash-involved

0

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 1996 compare to other T600 years?

T600 NHTSA complaints by model year, 1996 highlighted5 complaints1990: 1 complaints1991: 0 complaints1995: 0 complaints1996: 0 complaints1997: 2 complaints1998: 0 complaints1999: 2 complaints2000: 0 complaints2001: 0 complaints2002: 1 complaints2003: 3 complaints2004: 0 complaints2005: 5 complaints2006: 2 complaints2007: 1 complaints2008: 1 complaints2009: 0 complaints2010: 0 complaints2011: 0 complaints2013: 3 complaints2017: 0 complaints2018: 0 complaints2019: 0 complaints
T600 NHTSA complaints by model year, 1996 highlighted. Red bars are years to avoid.

See all T600 years to avoid →

Does the 1996 Kenworth T600 have recalls?

5 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

01V051000SuspensionFebruary 20, 2001 · 209 units

Defect

VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 54" REAR AXLE SPACING CONFIGURATION OF THE AIRGLIDE 200 SUSPENSION WITH THE SERVICE APPLICATION IDENTIFIED AS LOGGER, DUMP TRUCK, OR TANKER. THE REAR SUSPENSION IS REGULARLY SUBJECTED TO EXTREME ARTICULATION, RESULTING IN FLEXING OF THE JOINT.

Consequence

FAILURE OF THE LOWER SWAY ARM ATTACHING BOLTS COULD RESULT IN LOSS OF VEHICLE CONTROL.

Remedy

DEALERS WILL REPLACE THE LOWER SWAY ARM BRACKETS. OWNER NOTIFICATION BEGAN MARCH 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000.

98V129000Electrical SystemJune 11, 1998 · 9,500 units

Defect

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR 3406E ENGINES. THE ROUTING OF THE ELECTRICAL AND FUEL LINES CAN CAUSE CHAFFING OF THE WIRING HARNESS ON THE FUEL LINE.

Consequence

THIS CHAFFING CAN CAUSE FUEL LEAKAGE AND A POTENTIAL FOR A FIRE IN THE ENGINE COMPARTMENT.

Remedy

DEALERS WILL INSPECT, ADJUST, AND REPAIR, IF NECESSARY, THE FUEL LINE AND ELECTRICAL HARNESS.

97V196003SuspensionNovember 24, 1997 · 470 units

Defect

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH DESIGN LEVEL 1, ROCKWELL FF980 SERIES FRONT AXLE. THE FRONT AXLE HUB FLANGE CAN DEVELOP CRACKS DUE TO HIGH STRESS LEVELS.

Consequence

CRACKS IN A HUB FLANGE CAN RESULT IN A WHEEL SEPARATION.

Remedy

DEALERS WILL REMOVE AND REPLACE THE FRONT HUBS WITH AN IMPROVED DESIGN LEVEL 2 HUB.

97V139000SuspensionAugust 20, 1997 · 13,200 units

Defect

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH KENWORTH AIRGLIDE 200 REAR SUSPENSION. DUE TO MATERIALS USED IN THE SWAY BAR ARMS AND STUDS AS WELL AS THE STUD PLATING MATERIAL, STRESS CORROSION CRACKING AND BENDING FATIGUE CAN OCCUR IN THE REAR SUSPENSION SWAY BAR ARMS AND STUDS CAUSING THE STUD TO FAIL PREMATURELY.

Consequence

THIS COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE ARM ASSEMBLY MANUFACTURED FROM A DIFFERENT MATERIAL. NEW STUDS WILL BE INSTALLED WITH DIFFERENT THREADS AND DIFFERENT FINISH.

96V056000LightingApril 3, 1996 · 617 units

Defect

THE WIRES THAT CORRESPOND TO THE VEHICLE'S REAR TURN SIGNALS WERE REVERSED WHEN INSTALLED IN THE ELECTRICAL CONNECTOR.

Consequence

THIS CONDITION WILL CAUSE THE REAR TURN SIGNALS TO FLASH OPPOSITE FROM THE DIRECTION INTENDED BY THE DRIVER INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy

DEALERS WILL INSPECT THE TURN SIGNAL SWITCH AND, IF NECESSARY, REPLACE THE TURN SIGNAL SWITCH.

1996 Kenworth T600 — common questions

Is the 1996 Kenworth T600 reliable?

The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 5 recalls should be verified as completed.

Does the 1996 Kenworth T600 have recalls?

Yes — NHTSA lists 5 recall campaigns affecting the 1996 Kenworth T600. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.