Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 0 complaints on file for the 1977 Mack Hmm — too few to judge reliability from owner reports alone — but 4 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
0
NHTSA complaints
4
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
4 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 207, "SEATING SYSTEMS", AND 210, "SEAT BELT ASSEMBLY ANCHORAGES". VEHICLES EQUIPPED WITH VIKING T-BAR SEATS HAVE THE SEAT BELT ANCHORAGE LOCATED UNDER THE SEAT. THE TETHER BELT RUPTURED WHEN SUBJECTED TO THE FORCES REQUIRED IN THE SAFETY TEST.
Remedy
DEALER WILL RELOCATE THE TETHER BELT FLOOR ANCHORAGE TO CORRECT THE PROBLEM, WITHOUT CHARGE TO OWNER.
Defect
A DEFICIENCY EXISTS IN THE WELDS SECURING THE REAR SPRING INSULATOR BRACKET TO THE AXLE HOUSING. THIS IS DUE TO IMPROPER POSITIONING OF THE WELD, IN RELATIONSHIP TO THE BRACKET AND AXLE HOUSING. FAILURE OF THE WELDS WOULD CAUSE SEPARATION OF THE SPRING INSULATOR BRACKET AND THE AXLE HOUSING, RESULTING IN IMPROPER ALIGNMENT OF THE AFFECTED AXLE.
Remedy
DEALER WILL REWELD THE INSULATOR SPRING BRACKET AT NO COST TO OWNER.
Defect
THE FLEX BLADE FANS ON THE INVOLVED VEHICLES MAY DEVELOP CRACKS IN THE LAMINATED STIFFENER AS A RESULT OF FATIGUE DURING OPERATION. IF SUCH A CONDITION EXISTS AND THE CRACKS GO UNDETECTED, CONTINUED OPERATION COULD CAUSE PIECES OF THE STIFFENER TO BREAK OFF.
Remedy
DEALER WILL REPLACE THE ORIGINAL FAN WITH A STEEL FIXED BLADE FAN, FREE OF CHARGE.
Defect
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEATBELT ASSEMBLIES". ALTHOUGH THE SEATBELTS IN QUESTION PERFORMED MARGINALLY WITH RESPECT TO THE 5000 LB. LOAD REQUIREMENT, ADDITIONAL TESTING CONFIRMED THAT THE ANCHOR COULD FAIL, ALLOWING EITHER THE ANCHOR TO SLIP OVER THE HOLD-DOWN NUT OR THE ANCHOR TO SEPARATE INTO TWO PIECES.
Remedy
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE SEAT BELT ASSEMBLIES WITHOUT CHARGE TO OWNER.
The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 4 recalls should be verified as completed.
Yes — NHTSA lists 4 recall campaigns affecting the 1977 Mack Hmm. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.