1978 Mack RD problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 0 complaints on file for the 1978 Mack RD — too few to judge reliability from owner reports alone — but 7 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

NHTSA complaints

Recalls

Investigations

Crash-involved

Fires reported

Injuries

Deaths

—

NCAP overall

How does 1978 compare to other RD years?

RD NHTSA complaints by model year, 1978 highlighted. Red bars are years to avoid.

See all RD years to avoid →

Does the 1978 Mack RD have recalls?

7 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

79V133000EngineMay 31, 1979 · 23,000 units

Defect

IN THE EVENT OF TURBOCHARGER COMPRESSOR WHEEL FAILURE, ONE OR MORE OF THE FOUR CAPSCREWS THAT HOLD THE TURBOCHARGER TOGETHER MAY BE STRUCK BY PARTS OF THE COMPRESSOR WHEEL, RESULTING IN THE CAPSCREWS BEING DAMAGED. IF THESE CAPSCREWS ARE DAMAGED TO THE POINT THAT THEY ALLOW THE COMPRESSOR BACK PLATE TO DISLOCATE FROM THE TURBOCHARGER BEARING HOUSING, ENGINE LUBRICATING OIL MAY BE ALLOWED TO ESCAPE UNDER PRESSURE, CONTACTING THE ENGINE EXHAUST MANIFOLD SECTIONS OR TURBOCHARGER TURBINE HOUSING.

Remedy

DEALER WILL INSTALL A SHIELD FOR THE HEADS OF THE FOUR CAPSCREWS, ALONG WITH STRONGER SAE 8 GRADE 8 CAPSCREWS, IF NECESSARY, AT NO COST TO OWNER.

79V134000SteeringMay 30, 1979 · 64,150 units

Defect

IN THE INVOLVED TRUCKS IT IS POSSIBLE THE ADJUSTABLE STEERING COLUMN REAR MOUNTING BRACKET COULD FAIL, ALLOWING STEERING WHEEL ASSEMBLY TO FALL DOWN ONTO THE OPERATOR"S LAP.

Remedy

DEALER WILL INSTALL AN ADDITIONAL BRACKET IN THIS AREA TO PREVENT THE STEERING WHEEL FROM DISLOCATING IN THE EVENT OF A BRACKET FAILURE.

79V082000SteeringApril 3, 1979 · 12,000 units

Defect

AN IMPROPER PINCH BOLT AND NUT MAY HAVE BEEN USED IN THE CLAMPING OF THE STEERING SHAFT TO THE STEERING GEAR INPUT SHAFT. DUE TO CLAMPING FORCE LOADS APPLIED AT THE BOLT, THE NUT COULD YIELD, RESULTING IN LOOSENESS OF THE INPUT SHAFT YOKE. SHOULD THIS CONDITION GO UNNOTICED, SPLINE WEAR COULD CAUSE SHAFT SEPARATION.

Remedy

VEHICLES WILL BE INSPECTED AND, IF NECESSARY, THE CORRECT FASTENERS WILL BE INSTALLED AT NO CHARGE TO OWNER.

79V018000SuspensionJanuary 12, 1979 · 17 units

Defect

THE STEEL BRACKETS ON THE SUSPENSION BEAM WERE FOUND TO BE DEFICIENT DUE TO EXCESSIVE SHRINKAGE AND LOW MECHANICAL PROPERTIES. FAILURE OF ONE OR BOTH OF THESE BRACKETS COULD CAUSE A SEPARATION OF THE AXLE HOUSING FROM THE SUSPENSION.

Remedy

THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ANY SUSPECT BOGIE SPRING INSULATOR CAPS WITH NEW CAPS MEETING THE PROPER SPECIFICATIONS AT NO COST TO OWNER.

79V017000SuspensionJanuary 12, 1979 · 4,000 units

Defect

A CASTING DEFICIENCY EXISTS IN THE LOWER SECTION OF THE CAPS RESULTING IN A REDUCTION IN THE THICKNESS OF THE MATERIAL. FAILURE OF A CAP CAN ALLOW THE END OF THE REAR SPRING TO DETACH FROM THE AXLE HOUSING.

Remedy

DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ANY OF THE SPRING INSULATOR CAPS FOUND TO BE DEFECTIVE. THIS WILL BE DONE AT NO COST TO OWNER.

78V210000BrakesOctober 3, 1978 · 19,370 units

Defect

DELAYS OF UP TO ABOUT 2 SECONDS MAY EXIST IN THE BRAKE APPLICATION TIMES TO THE BRAKES ON THE BOGIE AXLES IN THE PRESENCE OF CERTAIN TYPES OF WHEEL SPEED SENSOR SIGNAL DISCONTINUITIES OR DISTORTIONS THAT MAY OCCUR AS A RESULT OF SENSOR WIRE FAILURE. THIS CONSTITUTES A NON-COMPLIANCE TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS".

Remedy

DEALER WILL INSTALL NEW WHEEL SPEED SENSORS THAT INCORPORATE IMPROVED WIRING AND THE PRESENT BOGIE ANTI-WHEEL LOCK SYSTEM WILL BE CHANGED TO AN AXLE-TO-AXLE SYSTEM FOR IMPROVED RELIABILITY.

78V172000SteeringAugust 8, 1978 · 13,800 units

Defect

THE EXISTING CROSS STEERING ARMS MAY HAVE INSUFFICIENT FATIGUE LIFE IN THE NECK AREA. THIS IS NEAR THE BOSS FOR THE CROSS STEERING TUBE BALL JOINT CONNECTION. FAILURE OF EITHER OF THE CROSS STEERING LEVERS COULD LEAD TO LOSS OF STEERING CONTROL OF THE RIGHT FRONT WHEEL.

Remedy

THE DEALER WILL INSPECT AND, IF NECESSARY, INSTALL CROSS STEERING ARMS OF IMPROVED DESIGN AND GREATER STRENGTH.

1978 Mack RD — common questions

Is the 1978 Mack RD reliable?

The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 7 recalls should be verified as completed.

Does the 1978 Mack RD have recalls?

Yes — NHTSA lists 7 recall campaigns affecting the 1978 Mack RD. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.

How does 1978 compare to other RD years?

Does the 1978 Mack RD have recalls?

1978 Mack RD — common questions

Is the 1978 Mack RD reliable?

Does the 1978 Mack RD have recalls?

Related