2024 Peterbilt 537 problems

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth T180, Peterbilt 535, 567, 2025-2026 Kenworth T280, 2023-2026 Kenworth T380, 2024-2026 Kenworth T480, 2024-2026 Peterbilt 536, 537, and 548 trucks. The exterior lighting switch may fail, resulting in the hazard lights and the instrument display back-light brightness adjustment not functioning. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 108, "Lamps, Reflective Devices and Associated Equipment."

Consequence

Inoperative hazard lights cannot alert other drivers as intended. In addition, the inability to adjust the brightness on the instrument panel display can make it difficult to see critical safety information or distract the driver. Both scenarios can increase the risk of a crash.

Remedy

Dealers will update the vehicle cab controller unit (VECU) software, free of charge. Owners are advised that a non-responsive switch can be temporarily reset by a key cycle. Owner notification letters were mailed March 26, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 25KWB and 25PBB.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2023-2024 Peterbilt 535, 536, 537, 548, 2023-2024 Kenworth T280, T380, T480, and 2024 Kenworth T180 trucks. The throttle pedal assembly may contain an oversized magnet carrier, slowing the responsiveness or causing the pedal to stick.

Consequence

A pedal that sticks increases the risk of a crash.

Remedy

Dealers will inspect and replace the throttle pedal as necessary, free of charge. Owner letters were mailed April 11, 2025. Owners may contact Peterbilt's customer service at 1-940-591-4220 and Kenworth's customer service at 1-425-828-5888. PACCAR's numbers for this recall are 25PBA and 25KWA.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.

Consequence

Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may not function properly or at all, increasing the risk of a crash.

Remedy

Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWL and 24PBL.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 537, 2024-2025 Kenworth T380, T480, Peterbilt 548, and 2025 Peterbilt 536 trucks, equipped with certain Meritor 10-16K and 18-23K front steer drive axles. The front steer drive axles may have insufficient wheel bearing lubricant.

Consequence

Insufficient lubrication may cause the wheel hub to overheat, increasing the risk of a fire, or result in a loss of vehicle control, increasing the risk of a crash.

Remedy

Dealers will inspect and repair the wheel end with new parts and lubricate the bearings as necessary, free of charge. Owner letters were mailed July 21, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 or Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWJ and 24PBJ.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communication.

Consequence

A loss of communication between the gear shifter and the transmission may result in the vehicle becoming disabled after coming to a stop, increasing the risk of a crash.

Remedy

Dealers will inspect and replace the gear shifter assembly as necessary, free of charge. Owner letters were mailed December 15, 2025, then phased after that. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24PBE and 24KWE.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.

Consequence

A loss of steering control increases the risk of a crash.

Remedy

Dealers will inspect and replace the steering gears as necessary, free of charge. Owner notification letters were mailed March 20, 2024. Owners may contact Peterbilt customer service at 1-940-591-4220 and/or Kenworth customer service at 1-425-828-5888. PACCAR's numbers for this recall are 24PBC and 24KWC.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2022-2024 Peterbilt 535, 536, 537, 548, and Kenworth T180, T280, T380, T480 trucks. The glass lock ring on the cab mirror assembly may not be fully seated, allowing the mirror glass to detach.

Consequence

A detached mirror glass can reduce driver visibility, increasing the risk of a crash.

Remedy

Dealers will inspect the mirror glass lock ring and repair it as necessary, free of charge. Owner letters were mailed February 23, 2024. Owners may contact Kenworth customer service at 1-425-828-5888 and/or Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWA and 24PBA.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Kenworth T280, T380, 2020-2024 Peterbilt 548, 536, 2024 Peterbilt 537, and 2020-2024 Kenworth T480 trucks. The timing of the trailer brake release may be delayed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Consequence

A delay in the trailer brake release can create instability to the trailer and increase the risk of a crash.

Remedy

Dealers will replace the fittings and hoses in the affected valves, free of charge. Owner letters were mailed January 15, 2024. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 23KWJ and 23PBJ.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2023-2024 Kenworth T280, T380, T480, Peterbilt 536, 537, and 548 trucks. The remote Stage 2 fuel filter hoses may have been damaged during production, allowing the hoses to leak or disconnect.

Consequence

A disconnected hose will result in an engine stall, increasing the risk of a crash. Also, a fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will replace both hoses, free of charge. Owner notification letters are expected to be mailed November 4, 2023. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 23KWF and 23PBF.

Defect

PACCAR Incorportated (PACCAR) is recalling certain 2023-2024 Peterbilt 536, 537, 548, 2023-2024 Kenworth T280, T480, and 2024 Kenworth T380 vehicles. The adhesive thread-lock may not have been applied to the four flange mounted yoke bolt threads, allowing the driveline fasteners to loosen.

Consequence

Loose fasteners may allow the driveline to separate from the truck, increasing the risk of a crash.

Remedy

Dealers will apply adhesive thread-lock and replace the fasteners, free of charge. Owner notification letters are expected to be mailed September 19, 2023. Owners may contact PACCAR's customer service at 1-425-828-5888 (Kenworth) or 1-940-591-4220 (Peterbilt). PACCAR's numbers for this recall are 23KWE and 23PBE.

Defect

PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Kenworth T280, T380, T480, Peterbilt 536, 537, and 548 vehicles. When the brake pedal is fully applied and then released rapidly, the pedal plunger that connects the brake pedal to the brake valve may become disconnected, causing the service brakes to fail.

Consequence

Service brake failure can increase the risk of a crash.

Remedy

Dealers will add a pedal restraint bracket, free of charge. Owner notification letters were mailed April 7, 2023. Owners may contact Kenworth's customer service at 1-425-828-588 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 23KWB and 23PBB.