VehicleVerdict

2007 Suzuki XL7 problems

Verdict · NHTSA data

One of the years to avoid

With 207 complaints filed to NHTSA — about 5.5 times the median XL7 year — the 2007 model ranks #1 of 9 XL7 years for complaint volume. It lands on the years-to-avoid list.

No single system dominates the record — complaints spread across fuel system (31), airbags (31), and engine (29), which usually points to general build quality rather than one defect.

207

NHTSA complaints

2

Recalls

0

Investigations

0

Crash-involved

5

Fires reported

2

Injuries

0

Deaths

—

NCAP overall

How does 2007 compare to other XL7 years?

XL7 NHTSA complaints by model year, 2007 highlighted207 complaints2001: 15 complaints2002: 42 complaints2003: 35 complaints2004: 63 complaints2005: 26 complaints2006: 38 complaints2007: 207 complaints2008: 119 complaints2009: 6 complaints
XL7 NHTSA complaints by model year, 2007 highlighted. Red bars are years to avoid.

See all XL7 years to avoid →

What are the most common 2007 Suzuki XL7 problems?

ComponentComplaintsShare
Airbags3115%
Fuel System3115%
Engine2914%
Steering2914%
Electrical System2814%
Other105%
Transmission105%
Visibility & Wipers84%
Tires & Wheels63%
Speed Control63%
Brakes52%
Body & Structure42%
Seats42%
Latches & Locks31%
Seat Belts21%
Climate Control (A/C & Heat)10%

Does the 2007 Suzuki XL7 have recalls?

2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

12V597000Fuel SystemDecember 20, 2012 · 2,830 units

Defect

American Suzuki is recalling certain model year 2007 XL-7 vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; and manufactured June 13, 2006, through December 22, 2006. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

Consequence

Fuel leakage in the presence of an ignition source may result in a fire.

Remedy

American Suzuki will notify owners, and dealers will replace the fuel pump module, free of charge. An interim letter was mailed on March 7, 2013. Owners may contact American Suzuki Customer Relations at 1-800-934-0934.

07V277000Visibility & WipersJune 14, 2007 · 921 units

Defect

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD.

Consequence

IN THE EVENT OF A CRASH, THE WINDSHIELD MAY NOT BE RETAINED TO THE EXTENT REQUIRED BY THE STANDARD, INCREASING THE RISK OF PERSONAL INJURIES TO THE VEHICLE OCCUPANTS.

Remedy

DEALERS WILL INSPECT AND REPLACE ANY GLASS (WINDSHIELD, LIFTGATE GLASS, OR THE SIDE STATIONARY GLASS) THAT WAS INSTALLED INCORRECTLY.THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“PASSENGER SIDE SEAT IS NOT RECOGNIZING A PASSENGER IS IN THE SEAT, SO AIR BAG IS OFF AND ALERT LIGHT STAYS ON AND OFF PERIODICALLY. THE LIGHT COMES ON ONCE WE ARE STATIONARY AND MAY GO OFF AND ON AS THE CAR IS IN MOTION. VEHICLE HAS 72200 MILES A AND I AM WORRIED THE AIR BAG WILL NOT DEPLOY IF…”

Complaint filed with NHTSA · Airbags · October 29, 2015

“TL* THE CONTACT OWNS A 2007 SUZUKI XL7. THE CONTACT STATED THAT THE VEHICLE WOULD NOT HOLD ANY FUEL AND HER HUSBAND NOTICED THAT THE FUEL PUMP HAD MELTED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 12V597000 (FUEL SYSTEM, GASOLINE). THE…”

Complaint filed with NHTSA · Fuel System · September 1, 2018 · fire

“TL* THE CONTACT OWNS A 2007 SUZUKI XL7. WHILE DRIVING APPROXIMATELY 25 MPH, THE TEMPERATURE GAUGE ABNORMALLY INCREASED AND THE ENGINE OVERHEATED. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE (NO FLAMES) UNDER THE HOOD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC…”

Complaint filed with NHTSA · Engine · April 15, 2015 · fire

“TL* THE CONTACT OWNS A 2007 SUZUKI XL7. WHILE THE VEHICLE WAS STATIONARY, THE POWER STEERING MALFUNCTIONED. THE CONTACT STATED THAT THE POWER STEERING MADE A SQUEAKING NOISE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE…”

Complaint filed with NHTSA · Steering · January 24, 2017

“TL* THE CONTACT OWNS A 2007 SUZUKI XL7. WHILE DRIVING APPROXIMATELY 25 MPH, THE TEMPERATURE GAUGE ABNORMALLY INCREASED AND THE ENGINE OVERHEATED. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED SMOKE (NO FLAMES) UNDER THE HOOD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC…”

Complaint filed with NHTSA · Electrical System · April 15, 2015 · fire

2007 Suzuki XL7 — common questions

Is the 2007 Suzuki XL7 reliable?

NHTSA data argues against it: 207 complaints put the 2007 model at #1 of 9 XL7 years. It is one of the XL7 years to avoid.

What are the most common 2007 XL7 problems?

According to NHTSA complaint data, the leading problem areas are fuel system (31 complaints), airbags (31 complaints), engine (29 complaints).

Does the 2007 Suzuki XL7 have recalls?

Yes — NHTSA lists 2 recall campaigns affecting the 2007 Suzuki XL7. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Which Suzuki XL7 years should you avoid?

Based on complaint rates and open investigations, the XL7 years to avoid are 2007, 2008, 2004. The cleanest record among XL7 years belongs to 2009.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.