2002 Ud UD1200 problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 0 complaints on file for the 2002 Ud UD1200 — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

NHTSA complaints

Recalls

Investigations

Crash-involved

Fires reported

Injuries

Deaths

—

NCAP overall

How does 2002 compare to other UD1200 years?

UD1200 NHTSA complaints by model year, 2002 highlighted. Red bars are years to avoid.

See all UD1200 years to avoid →

Does the 2002 Ud UD1200 have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

05V261000Electrical SystemJune 2, 2005 · 2,744 units

Defect

CERTAIN LIGHT DUTY TRUCKS MAY HAVE HAD THE OUTER CORRUGATED PROTECTIVE CONDUIT FOR THE BATTERY CABLE WORN THROUGH AT THE REAR TRANSMISSION MOUNTING BRACKET AND THE BATTERY CABLE MAY RUB AGAINST THE EDGE OF THE THIRD FRAME CROSS MEMBER SUPPORT AND ALLOW THE BATTERY CABLE TO SHORT AGAINST THE FRAME.

Consequence

THIS COULD CAUSE AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE BATTERY CABLE WITH A REDESIGNED CABLE THAT WILL PREVENT MOVEMENT OF THE CABLE INSIDE THE CORRUGATED PROTECTIVE CONDUIT AND A PROTECTIVE EDGE GUARD WILL BE INSTALLED ON THE LOWER EDGE OF THE THIRD CHASSIS FRAME ACROSS MEMBER SUPPORT. THE RECALL BEGAN ON SEPTEMBER 19, 2005. OWNERS MAY CONTACT NISSAN DIESEL AMERICA AT 972-756-5500.

05V262000Electrical SystemJune 2, 2005 · 3,857 units

Defect

ON CERTAIN LIGHT DUTY TRUCKS, THE BATTERY CABLE MAY HAVE BEEN ROUTED INCORRECTLY DURING VEHICLE MANUFACTURING THAT COULD ALLOW THE BATTERY CABLE TO CONTACT THE EDGE OF THE REAR TRANSMISSION MOUNTING BRACKET. DURING NORMAL VEHICLE OPERATION THE BATTERY CABLE CORRUGATED PROTECTIVE CONDUIT COULD BECOME WORN AWAY AND ALLOW SHORTING OF THE POSITIVE BATTERY CABLE TO THE FRAME.

Consequence

THIS COULD CAUSE AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.

Remedy

FOR MY 1999-2000 MODELS, DEALERS WILL INSPECT AND REROUTE THE CABLE CORRECTLY TO THE SMOOTH SIDE OF THE REAR TRANSMISSION MOUNTING BRACKET AND SECURE IT TO THE CHASSIS WIRING HARNESS AS DESIGNED OR WILL HAVE THE POSITIVE BATTERY CABLE REPLACED. FOR MY 2001-2002, DEALERS WILL SECURE THE BATTERY CABLE TO THE ADJACENT CHASSIS WIRING HARNESS WITH A PLASTIC TIE STRAP TO PREVENT EXCESSIVE MOVEMENT OF THE CABLE OR IF THE CORRUGATED PROTECTIVE CONDUIT WORN THROUGH NEAR THE REAR TRANSMISSION MOUNTING BRACKET OR THE THIRD FRAME CROSS MEMBER SUPPORT WILL BE REPLACED. THE RECALL BEGAN ON ON SEPTEMBER 19, 2005. OWNERS MAY CONTACT NISSAN DIESEL AT 972-756-5500.

03V224000Seat BeltsJune 16, 2003 · 1,661 units

Defect

ON CERTAIN LIGHT DUTY TRUCKS, THE PASSENGER SEAT BELT MAY HAVE THE INCORRECT SEAT BELT ANCHOR INSTALLED.

Consequence

IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL INSPECT THE VEHICLES AND REPLACE THE PASSENGER SEAT FRAME/ANCHOR, IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 20, 2003. OWNERS SHOULD CONTACT NISSAN DIESEL AT 1-972-756-5500.

2002 Ud UD1200 — common questions

Is the 2002 Ud UD1200 reliable?

The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.

Does the 2002 Ud UD1200 have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2002 Ud UD1200. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.

How does 2002 compare to other UD1200 years?

Does the 2002 Ud UD1200 have recalls?

2002 Ud UD1200 — common questions

Is the 2002 Ud UD1200 reliable?

Does the 2002 Ud UD1200 have recalls?

Related