VehicleVerdict

2009 Volvo S40 problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 14 complaints on file for the 2009 Volvo S40 — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

14

NHTSA complaints

3

Recalls

0

Investigations

0

Crash-involved

3

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 2009 compare to other S40 years?

S40 NHTSA complaints by model year, 2009 highlighted166 complaints2000: 166 complaints2001: 112 complaints2002: 34 complaints2003: 23 complaints2004: 75 complaints2005: 91 complaints2006: 81 complaints2007: 36 complaints2008: 27 complaints2009: 14 complaints2010: 11 complaints2011: 7 complaints
S40 NHTSA complaints by model year, 2009 highlighted. Red bars are years to avoid.

See all S40 years to avoid →

What are the most common 2009 Volvo S40 problems?

ComponentComplaintsShare
Transmission321%
Other214%
Engine214%
Tires & Wheels214%
Suspension17%
Lighting17%
Electrical System17%
Fuel System17%
Brakes17%

Does the 2009 Volvo S40 have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

10V591000SeatsNovember 22, 2010 · 7,420 units

Defect

VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.

Consequence

POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.

Remedy

DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.

10V566000Electrical SystemNovember 8, 2010 · 416 units

Defect

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence

AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy

VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

08V329000SteeringJuly 23, 2008 · 1,020 units

Defect

VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.

Consequence

THIS CAN RESULT IN A RAPID DRAINAGE OF THE POWER STEERING FLUID IN THE SYSTEM AND A COMPLETE LOSS OF POWER ASSISTANCE, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT AND REPLACE THE STEERING RETURN LINE HOSE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 13, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“TL* THE CONTACT OWNS A 2009 VOLVO S40. WHILE DRIVING APPROXIMATELY 25 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FUEL LINE WAS…”

Complaint filed with NHTSA · Transmission · February 24, 2015

“MY WIFE WAS DRIVING HOME FROM A GROCERY STORE 3 MILES AWAY. A QUARTER MILE FROM THE HOUSE SHE NOTICED A BURNING SMELL. SHE THOUGHT IT WAS FROM THE OUTSIDE SINCE BRUSH FIRES ARE COMMON AROUND SOUTH FL. SHE PARKED ONTO OUR DRIVEWAY AND NOTICED SMOKE RISING FROM AROUND THE HOOD. SHE TOOK THE KEY OFF…”

Complaint filed with NHTSA · Engine · October 22, 2013 · fire

“TIRE PRESSURE MONITORING SYSTEM (TPMS) FAILURE WHICH ALMOST RESULTED IN A CRASH AT HIGH SPEED. TPMS AIR STEM BROKE WHILE DRIVING. THE TPMS THEN FELL INTO THE TIRE, LEAVING THE AIR STEM HOLE WIDE OPEN, WHICH RESULTED IN RAPID DEFLATION OF THE TIRE. OPERATOR OF THE VEHICLE WAS ABLE TO BARELY KEEP…”

Complaint filed with NHTSA · Tires & Wheels · July 1, 2012

“IMPROPER DRAINING ROUTE WHICH IN RESULT CAUSES MOLD AND DAMAGE TO FLOOR MATS AND SEAT CUSHIONS IN RAINY WEATHER. TRANSMISSION FLUID HAS HIGHER ACIDITY LEVELS. COOLANT REGULARLY FALLS BELOW MINIMUM LEVEL REQUIRED.”

Complaint filed with NHTSA · Other · May 7, 2017

“HEADLIGHT WIRING- MADE AN ATTEMPT TO CHANGE LIGHT BULBS FOR HEADLAMPS. COVERING AROUND ELECTRICAL WIRING HARNESS WHICH CONNECT TO HEADLIGHT CRUMBLED IN MY HANDS AND ELECTRICAL WIRING IS EXPOSED. WORRIES THAT THIS MAY BE POTENTIAL FIRE HAZARD TO MY VEHICLE AND MYSELF. MY VEHICLE WAS STATIONARY IN MY…”

Complaint filed with NHTSA · Lighting · December 3, 2018

2009 Volvo S40 — common questions

Is the 2009 Volvo S40 reliable?

The record is thin — 14 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.

What are the most common 2009 S40 problems?

According to NHTSA complaint data, the leading problem areas are transmission (3 complaints), engine (2 complaints), tires & wheels (2 complaints).

Does the 2009 Volvo S40 have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2009 Volvo S40. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Which Volvo S40 years should you avoid?

Based on complaint rates and open investigations, the S40 years to avoid are 2000, 2001, 2005, 2006, 2004. The cleanest record among S40 years belongs to 2011.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.