2009 Volvo Vnm problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 3 complaints on file for the 2009 Volvo Vnm — too few to judge reliability from owner reports alone — but 2 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

NHTSA complaints

Recalls

Investigations

Crash-involved

Fires reported

Injuries

Deaths

—

NCAP overall

How does 2009 compare to other Vnm years?

Vnm NHTSA complaints by model year, 2009 highlighted. Red bars are years to avoid.

See all Vnm years to avoid →

What are the most common 2009 Volvo Vnm problems?

Component	Complaints	Share	vs prior year
Engine	2	67%	▲ up
Trailer Hitch	1	33%	— flat

Does the 2009 Volvo Vnm have recalls?

2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

13V268000TransmissionJune 26, 2013 · 23,056 units

Defect

Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.

Consequence

Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.

Remedy

Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.

10V492000OtherOctober 12, 2010 · 1,926 units

Defect

VOLVO IS RECALLING CERTAIN MODEL YEAR 2008-2011 VHD, VNL, VNM, AS WELL AS 2008-2010 VT VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE TIRE DESCRIPTION MAY BE INCORRECT ON THE VEHICLE'S CERTIFICATION LABEL.

Consequence

THE MISINFORMATION ON THESE LABELS COULD LEAD TO A VEHICLE OVERLOADING THAT CAN INCREASE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT AND REPLACE THE LABELS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 25, 2011. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“MY OTHER ISSUE WITH THIS TRUCK IS. THE EMISSIONS SYSTEM IS NOT SAFE TO OPERATE. IF THE TRUCK'S COMPUTER CANNOT DETECT IF THERE IS A PLUGGED DPF/DOC FILTER ON THE EXHAUST SYSTEM THE DRIVER CANNOT MANUALLY ACTUATE A REGEN CYCLE. THE ENGINE'S EXHAUST STREAM STAYS PLUGGED AND CAN LEAD TO VERY DANGEROUS…”
Complaint filed with NHTSA · Engine · November 22, 2019

“2009 VOLVO SEMI, WAS WESTBOUND WHEN HIS TRAILER BECAME DISCONNECTED FROM THE TRACTOR AND WENT OFF THE RIGHT SIDE OF THE ROAD AND STRUCK THE GUARDRAIL. *BF (OHIO TRAFFIC CRASH REPORT # 10-0372-89)*JB”
Complaint filed with NHTSA · Trailer Hitch · September 1, 2010 · crash

2009 Volvo Vnm — common questions

Is the 2009 Volvo Vnm reliable?

The record is thin — 3 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 2 recalls should be verified as completed.

Does the 2009 Volvo Vnm have recalls?

Yes — NHTSA lists 2 recall campaigns affecting the 2009 Volvo Vnm. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Is the 2009 Volvo Vnm under NHTSA investigation?

NHTSA opened 3 investigations into this model year; all are now closed.

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.

How does 2009 compare to other Vnm years?

What are the most common 2009 Volvo Vnm problems?

Does the 2009 Volvo Vnm have recalls?

Consumer complaints filed with NHTSA

2009 Volvo Vnm — common questions

Is the 2009 Volvo Vnm reliable?

Does the 2009 Volvo Vnm have recalls?

Is the 2009 Volvo Vnm under NHTSA investigation?

Related