2001 Volvo Wxll problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 0 complaints on file for the 2001 Volvo Wxll — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

NHTSA complaints

Recalls

Investigations

Crash-involved

Fires reported

Injuries

Deaths

—

NCAP overall

How does 2001 compare to other Wxll years?

Wxll NHTSA complaints by model year, 2001 highlighted. Red bars are years to avoid.

See all Wxll years to avoid →

Does the 2001 Volvo Wxll have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

03V308000TransmissionAugust 22, 2003 · 3,426 units

Defect

ON CERTAIN HEAVY-DUTY CLASS 8 VEHICLES, THE BODY BUILDER WIRING OPTION WAS MIS-WIRED IN SUCH A WAY THAT THE AUTO NEUTRAL WITH SERVICE BRAKE STATUS OPTION MAY ALLOW THE TRANSMISSION TO GO INTO FORWARD GEAR WITHOUT THE DRIVER'S FOOT PRESSING DOWN ON THE BRAKE PEDAL FIRST.

Consequence

UNINTENDED MOVEMENT OF THE VEHICLE COULD PUT PERSONS IN DANGER INSIDE AND OUTSIDE THE VEHICLE.

Remedy

VOLVO TRUCKS WILL NOTIFY ITS CUSTOMERS AND INSTALL AN ADDITIONAL AIR OPERATED STOP LIGHT SWITCH AND THE NECESSARY WIRING CHANGES. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT 1-800-528-6586.

03V183000EngineMay 15, 2003 · 120 units

Defect

ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.

Consequence

IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE ELECTRONIC CONTROL MODULE CALIBRATION FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357 OR VOLVO TRUCK AT 1-800-528-6586.

02V036000TransmissionFebruary 5, 2002 · 215 units

Defect

ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT CAN BREAK ALLOWING THE AXLE TO SHIFT OUT OF ALIGNMENT.

Consequence

THIS COULD RESULT IN A LOSS OF AXLE STABILITY INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT THE UPPER AXLE SEAT FOR A CERTAIN DATE CODE THAT IS STAMPED ON THE PART, AND THOSE AXLES WILL BE REPLACED. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

2001 Volvo Wxll — common questions

Is the 2001 Volvo Wxll reliable?

The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.

Does the 2001 Volvo Wxll have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2001 Volvo Wxll. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.

How does 2001 compare to other Wxll years?

Does the 2001 Volvo Wxll have recalls?

2001 Volvo Wxll — common questions

Is the 2001 Volvo Wxll reliable?

Does the 2001 Volvo Wxll have recalls?

Related