Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 0 complaints on file for the 1981 Western Rws Series — too few to judge reliability from owner reports alone — but 5 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
0
NHTSA complaints
5
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
5 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
SPRING SEAT CAN DEFORM, WHICH CAUSES A DECREASE IN THE CLAMPING FORCE IN THE SUSPENSION ASSEMBLY. LOSS OF CLAMPING FORCE MAY BRING ABOUT AXLE MISALIGNMENT OR AXLE HOUSING FAILURE.
Remedy
THE AXLE HOUSING WILL BE INSPECTED AND REPLACED, IF NECESSARY. THE SPRING SEATS WILL ALSO BE REPLACED.
Defect
FRONT AXLE AIR BRAKE LINES ARE ROUTED TOO CLOSE TO THE ENGINE EXHAUST MANIFOLD. THIS CAN PERMIT BRAKE LINES TO MELT AND RUPTURE, CAUSING A REDUCTION IN AIR PRESSURE TO BRAKE CHAMBERS UPON BRAKE APPLICATION.
Remedy
FRONT AXLE AIR BRAKE LINES WILL BE REPLACED, EMPLOYING NEW ROUTING AND HEAT RESISTANCE IMPROVEMENTS.
Defect
THE THROTTLE RETURN SPRINGS ON THE AFFECTED VEHICLES PROVIDE LESS THAN THE REQUIRED TORQUE, CAUSING A SLUGGISH RETURN OF THE THROTTLE TO THE IDLE POSITION AFTER THE ACCELERATOR PEDAL IS RELEASED. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS".
Remedy
NEW ANCHOR BRACKETS AND SPRING EXTENSIONS FOR THE THROTTLE RETURN SPRINGS, WILL BE INSTALLED AT CORRECTED LOCATIONS WITHOUT CHARGE TO OWNER.
Defect
INADEQUATE WELD POSITIONING COUPLED WITH RADIUS ROD LOAD AND LOOSENING OF THE SPRING CLIP NUTS COULD CAUSE SPRING SEAT FRACTURE. THIS CAN RESULT IN LOSS OF DIRECTIONAL CONTROL OF THE AXLE.
Remedy
SPRING SEAT RADIUS ROD BRACKETS WILL BE INSPECTED AND REPLACED IF NECESSARY. IN ADDITION, SUPPLEMENTAL BRACKETS WILL BE INSTALLED TO REINFORCE THE SPRING SEAT, WITHOUT CHARGE.
Defect
DUE TO A DEFICIENCY IN MATERIAL STRENGTH, THE FRONT ENGINE SUPPORT BRACKETS ON THE INVOLVED VEHICLES MAY DEVELOP CRACKS THAT COULD LEAD TO BRACKET FAILURE. THIS WOULD CAUSE THE ENGINE TO DROP DOWN INTO THE RADIATOR, DAMAGING THE SHROUD, ENGINE FAN, AND OTHER ASSOCIATED PARTS. THE ENGINE THROTTLE COULD BE PULLED INTO FULL GOVERNED POSITION.
Remedy
THE EXISTING SUPPORT BRACKETS WILL BE REPLACED WITH BRACKETS MADE OF DUCTILE IRON, AT NO CHARGE TO OWNER.
The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 5 recalls should be verified as completed.
Yes — NHTSA lists 5 recall campaigns affecting the 1981 Western Rws Series. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.