VehicleVerdict

2010 BMW X3 Sav problems

Verdict · NHTSA data

One of the years to avoid

The 2010 BMW X3 Sav carries two red flags at once: 27 consumer complaints filed with NHTSA and an open NHTSA defect investigation (subject: Desiccated Air Bag Inflator Rupture). It is one of the X3 Sav years to avoid.

27

NHTSA complaints

3

Recalls

1

Investigations · 1 open

2

Crash-involved

1

Fires reported

2

Injuries

0

Deaths

—

NCAP overall

How does 2010 compare to other X3 Sav years?

X3 Sav NHTSA complaints by model year, 2010 highlighted195 complaints2007: 195 complaints2008: 74 complaints2009: 22 complaints2010: 27 complaints2011: 18 complaints2012: 7 complaints
X3 Sav NHTSA complaints by model year, 2010 highlighted. Red bars are years to avoid.

See all X3 Sav years to avoid →

What are the most common 2010 BMW X3 Sav problems?

ComponentComplaintsShare
Airbags1556%
Engine311%
Steering311%
Body & Structure27%
Electrical System27%
Other14%
Visibility & Wipers14%

Does the 2010 BMW X3 Sav have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

22V119000EngineMarch 2, 2022 · 917,106 units

Defect

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence

An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy

This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.

16V071000AirbagsFebruary 5, 2016 · 840,000 units

Defect

BMW of North America, LLC (BMW) is recalling certain model year 2008-2013 128i and 135i coupes and convertibles and 1 Series M coupes, 2006-2011 325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi, 335i, 335xi, 335i xDrive Sedans, 2009-2011 335d sedans, 2006-2012 325xiT, 328i and 328xi sports wagons, 2007-2013 328i, 328xi, 328i xDrive, 335i, 335xi, 335i xDrive, 335is and M3 Coupes and Convertibles, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i SAVs, 2007-2010 X3 xDrive30i SAVs, 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M SAVs, 2009-2013 BMW X5 xDrive35d SAVs, 2008-2014 X6 xDrive35i, X6 xDrive50i, and X6 M SACs, 2010-2011 BMW X6 xDrive50i SACs and 2008-2011 M3 Sedan vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy

BMW will notify owners, and dealers will replace the driver's frontal air bag module or inflator depending on the vehicle model, free of charge. The recall began March 9, 2018. Owners may contact BMW customer service at 1-800-525-7417.

14V176000EngineApril 10, 2014 · 156,137 units

Defect

BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.

Consequence

If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.

Remedy

BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.

Open NHTSA investigations

EA21002

Desiccated Air Bag Inflator Rupture

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW X3 SAV. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF THREE LANES OF TRAFFIC. THE CONTACT EXITED THE VEHICLE WHILE THE PASSENGER REMAINED INSIDE. ANOTHER VEHICLE DRIVING AT A HIGH RATE OF SPEED CRASHED INTO THE REAR OF…”

Complaint filed with NHTSA · Airbags · January 27, 2014 · crash

“TL*THE CONTACT OWNS A 2010 BMW X3. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE POWER STEERING SYSTEM MALFUNCTIONED AND CAUSED THE STEERING WHEEL TO SEIZE. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER, WHO DIAGNOSES THE VEHICLE AS HAVING A DEFECTIVE POWER STEERING PUMP. THE DEALER DID NOT…”

Complaint filed with NHTSA · Steering · August 23, 2013

“TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW X3 SAV. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF THREE LANES OF TRAFFIC. THE CONTACT EXITED THE VEHICLE WHILE THE PASSENGER REMAINED INSIDE. ANOTHER VEHICLE DRIVING AT A HIGH RATE OF SPEED CRASHED INTO THE REAR OF…”

Complaint filed with NHTSA · Engine · January 27, 2014 · crash

“MY WIFE WAS DRIVING THE CAR AND SHE HEARD A CLINKING SOUND, IT WAS THE SUN ROOF GLASS THAT SHATTERED. MY WIFE STOPPED AT A HARDWARE STORE TAPED THE GLASS, AND COVERED IT WITH PLASTIC. THE GLASS COULD HAVE FLOWN OFF AND DAMAGES CARS( INCLUDING OURS) AND INJURED PEOPLE. *TR”

Complaint filed with NHTSA · Body & Structure · February 21, 2013

“MANY DASHBOARD WARNING LIGHTS CAME ON SIMULTANEOUSLY WHILE DRIVING. TOOK TO BMW OF ROCKVILLE MD. THEY DIAGNOSED FAILURE OF "FAULTY STEERING ANGLE SENSOR AND COIL SPRING." THEY CONFIRMED THIS WAS A SAFETY ISSUE, AND THAT IT WAS NOTHING WE DID THAT CAUSED IT-- IT WAS A FAULTY PART. AFTER ONLY 33,000…”

Complaint filed with NHTSA · Electrical System · August 29, 2015

2010 BMW X3 Sav — common questions

Is the 2010 BMW X3 Sav reliable?

NHTSA data argues against it: 27 complaints put the 2010 model at #3 of 6 X3 Sav years, and a defect investigation remains open. It is one of the X3 Sav years to avoid.

What are the most common 2010 X3 Sav problems?

According to NHTSA complaint data, the leading problem areas are airbags (15 complaints), engine (3 complaints), steering (3 complaints).

Does the 2010 BMW X3 Sav have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2010 BMW X3 Sav. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Is the 2010 BMW X3 Sav under NHTSA investigation?

Yes — an investigation remains open (Desiccated Air Bag Inflator Rupture). An open ODI action means NHTSA is actively assessing a possible defect.

Which BMW X3 Sav years should you avoid?

Based on complaint rates and open investigations, the X3 Sav years to avoid are 2007, 2008, 2010, 2009, 2011, 2012.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.