Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just one complaint on file for the 1991 Chevrolet P3 — too few to judge reliability from owner reports alone — but 4 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
1
NHTSA complaints
4
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Brakes | 1 | 100% | new |
4 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
THE 19.5 X 6 FRONT STEEL WHEEL DISC CRACKS OUTSIDE THE MOUNTING BOLT CIRCLE AND ENDS AT THE HUB'S DIAMETER.
Consequence
IF THE CRACKING GOES UNNOTICED, THE CENTER PORTION OF THEDISC WILL CRACK COMPLETELY AND EVENTUALLY THE RIM PORTION OF THE WHEEL COULDSEPARATE FROM THE CENTER SECTION WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy
REPLACE ALL SIX (SEVEN IF THERE IS A SPARE) DEFECTIVE WHEELS WITH NEWLY DESIGNED WHEELS.
Defect
SOME CHASSIS WERE SHIPPED TO BODY BUILDERS WITH DAMAGED FILL OR VENT OPENING CAPS ON THE RIGHT-HAND SIDE. IF A LEFT-HAND FILL SYSTEM WAS INSTALLED ON THE TANK, AND THERE WAS A DAMAGED RIGHT-HAND CAP, THE FUEL SYSTEM WOULD NOT BE SEALED.
Consequence
IF THE FUEL SYSTEM IS NOT SEALED, THE AUTOMATIC SHUT-OFFSYSTEM USED IN GAS STATIONS WOULD NOT WORK, ALLOWING GAS TO BE FORCED OUT OFTHE DEFECTIVE RIGHT-HAND OPENING. THE SPILLED GASOLINE WOULD RESULT IN A FIREHAZARD IF EXPOSED TO A SOURCE OF IGNITION.
Remedy
INSTALL NEW CAPS ON THE VEHICLES WITH UNUSED RIGHT-HAND FILL OR VENT OPENINGS.
Defect
THE AUTOMATIC APPLY TRANSMISSION MOUNTED PARKING BRAKE LEVER PIVOT BOLT "FINGER" MAY BE LOOSE.
Consequence
THE LOOSE PIVOT BOLT COULD ALLOW THE PARKING BRAKES TORELEASE AFTER THEY HAVE BEEN SET MANUALLY; IF THE BOLT FALLS OFF WHEN THEAUTOMATIC APPLY PARKING BRAKE IS SET, THERE IS INSUFFICIENT BRAKING TO HOLD THEVEHICLE IF IT IS PARKED ON AN INCLINE. BOTH OF THESE CONDITIONS COULD RESULT INVEHICLE MOVEMENT WITHOUT PRIOR WARNING AND POSSIBLY IN AN ACCIDENT.
Remedy
TORQUE PIVOT BOLT TO SPECIFICATIONS.
Defect
BRAKES MAY HAVE MISSING REAR AXLE OUTER BEARING RETAINING RING AND OR GREATER THAN SPECIFIED BEARING END PLAY. EITHER CONDITION ALLOWS THE ROTOR AND HUB ASSEMBLY TO SHIFT POSITION RELATIVE TO THE SPINDLE. THIS MOVEMENT CAN CAUSE BRAKE CALIPER PISTON RECEDE FARTHER THAN NORMAL INTO THE PISTON BORE WHICH WOULD REQUIRE GREATER THAN NORMAL BRAKE FLUID DISPLACEMENT WHEN THE SERVICE BRAKES ARE APPLIED.
Consequence
THIS CONDITION LEADS TO INCREASED STOPPING DISTANCE, ANDSHOULD MINIMUM STOPPING DISTANCE BE REQUIRED, IT COULD RESULT IN AN ACCIDENTWITHOUT WARNING.
Remedy
REPLACE BOTH REAR AXLE HUBS.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“TEAMS CHEVROLET 90C51/91V123. OWNER AWAITS REPAIR, IT HAS BEEN ONE MONTH. ZONE STATES WE HAVE NOTHING TO DO WITH SCHEDULE APPOINTMENTS. *AK”
The record is thin — 1 NHTSA complaint — so owner-report data can't strongly confirm reliability either way, though 4 recalls should be verified as completed.
Yes — NHTSA lists 4 recall campaigns affecting the 1991 Chevrolet P3. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.