VehicleVerdict

2002 Damon Intruder problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 8 complaints on file for the 2002 Damon Intruder — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

8

NHTSA complaints

3

Recalls

0

Investigations

0

Crash-involved

0

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 2002 compare to other Intruder years?

Intruder NHTSA complaints by model year, 2002 highlighted17 complaints1994: 2 complaints1997: 4 complaints1998: 2 complaints1999: 2 complaints2000: 0 complaints2001: 0 complaints2002: 8 complaints2003: 17 complaints2004: 4 complaints2005: 6 complaints2006: 2 complaints2007: 0 complaints2008: 0 complaints
Intruder NHTSA complaints by model year, 2002 highlighted. Red bars are years to avoid.

See all Intruder years to avoid →

What are the most common 2002 Damon Intruder problems?

ComponentComplaintsShare
Brakes225%
Body & Structure225%
Fuel System113%
Other113%
Transmission113%
Visibility & Wipers113%

Does the 2002 Damon Intruder have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

09V225000BrakesJune 16, 2009 · 2,415 units

Defect

DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.

Consequence

THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

07V130000OtherMarch 20, 2007 · 25,128 units

Defect

CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy

DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.

03V080000BrakesMarch 5, 2003 · 2,656 units

Defect

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Remedy

DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION IS BEGAN MAY 12, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAMON AT 1-219-272-9212.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“I HAD A SAFETY RECALL # 50401C DONE ON 05/09/2006 TO REPLACE ALL 4 CALIPERS BECAUSE THEY MIGHT HANG UP AND CAUSE BRAKE OVERHEATING AND MAYBE A ACCIDENT. AT THAT TIME THERE WAS NO DAMAGE AND NO WORN OF CRACKED PARTS. I WAS ASKED TO RETURN AGAIN FOR RECALL # 51101C TO AGAIN REPLACE ALL 4 CALIPERS TO…”

Complaint filed with NHTSA · Brakes · May 2, 2011

“LEFT TOP CORNER WINDSHIELD SEAL FAILED, AND WAS LEAKING A LOT OF WATER. (2002 DAMON INTRUDER 369)*AK THE WINDSHIELD CAME OUT AT THE TOP LEFT HAND CORNER AND CAUSED WATER TO ENTER THE RV. THE DEALER INDICATED THAT THEY DIDN'T THINK IT WOULD STAY IN PLACE BECAUSE OF STRUCTURAL CONDITIONS THAT CAUSED…”

Complaint filed with NHTSA · Body & Structure · October 6, 2003

“CONSUMER HAD DIFFICULTY CHECKING TRANSMISSION FLUID. THE DEALER HAD ATTEMPTED TO REPAIR THE VEHICLE 3 TIMES UNSUCCESSFULLY. *TS *AK THERE WAS A RATTLE NOISE, THE BATHROOM WAS OUT OF LINE, THE DOOR /EXIT DOOR DIDN'T STAY CLOSED, THE TANK LEAKED, THE WINDSHIELD WIPER WAS INOPERATIVE, AND THE ANTENNA…”

Complaint filed with NHTSA · Other · January 1, 2003

“CONSUMER HAD DIFFICULTY CHECKING TRANSMISSION FLUID. THE DEALER HAD ATTEMPTED TO REPAIR THE VEHICLE 3 TIMES UNSUCCESSFULLY. *TS *AK THERE WAS A RATTLE NOISE, THE BATHROOM WAS OUT OF LINE, THE DOOR /EXIT DOOR DIDN'T STAY CLOSED, THE TANK LEAKED, THE WINDSHIELD WIPER WAS INOPERATIVE, AND THE ANTENNA…”

Complaint filed with NHTSA · Transmission · January 1, 2003

“CONSUMER HAD DIFFICULTY CHECKING TRANSMISSION FLUID. THE DEALER HAD ATTEMPTED TO REPAIR THE VEHICLE 3 TIMES UNSUCCESSFULLY. *TS *AK THERE WAS A RATTLE NOISE, THE BATHROOM WAS OUT OF LINE, THE DOOR /EXIT DOOR DIDN'T STAY CLOSED, THE TANK LEAKED, THE WINDSHIELD WIPER WAS INOPERATIVE, AND THE ANTENNA…”

Complaint filed with NHTSA · Visibility & Wipers · January 1, 2003

2002 Damon Intruder — common questions

Is the 2002 Damon Intruder reliable?

The record is thin — 8 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.

Does the 2002 Damon Intruder have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2002 Damon Intruder. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.