VehicleVerdict

2015 Ford E-450 problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 8 complaints on file for the 2015 Ford E-450 — too few to judge reliability from owner reports alone — but one recall campaign applies to this year, so any used example should have its VIN checked for completed recall work.

8

NHTSA complaints

1

Recalls

1

Investigations

0

Crash-involved

0

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 2015 compare to other E-450 years?

E-450 NHTSA complaints by model year, 2015 highlighted83 complaints1992: 0 complaints1993: 5 complaints1994: 0 complaints1995: 0 complaints1996: 1 complaints1997: 18 complaints1998: 6 complaints1999: 83 complaints2000: 45 complaints2001: 20 complaints2002: 16 complaints2003: 22 complaints2004: 45 complaints2005: 41 complaints2006: 26 complaints2007: 15 complaints2008: 10 complaints2009: 2 complaints2010: 6 complaints2011: 10 complaints2012: 6 complaints2013: 16 complaints2014: 5 complaints2015: 8 complaints2016: 22 complaints2017: 16 complaints2018: 5 complaints2019: 4 complaints2021: 51 complaints2022: 22 complaints2023: 3 complaints2024: 3 complaints2025: 5 complaints2026: 6 complaints2027: 0 complaints
E-450 NHTSA complaints by model year, 2015 highlighted. Red bars are years to avoid.

See all E-450 years to avoid →

What are the most common 2015 Ford E-450 problems?

ComponentComplaintsShare
Transmission338%
Tires & Wheels225%
Engine113%
Fuel System113%
Suspension113%

Does the 2015 Ford E-450 have recalls?

1 NHTSA recall campaign on file. Recall repairs are free at franchised dealers.

19V313000SeatsApril 18, 2019 · 2,080 units

Defect

Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

Consequence

In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

Remedy

MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“THIS IS A SCHOOL BUS. WHEN STOPPED AT A STOP SIGN THE SCHOOL BUS WOULD NOT ENGAGE IN ANY GEAR, FORWARD OR REVERSE. THE SCHOOL BUS HAD TO BE TOWED TO THE FORD DEALERSHIP WHERE THEY FOUND THAT THE COAST CLUTCH DRUM, RETURN SPRING, PISTON AND ONE WAY CLUTCH NEEDED TO BE REPLACED. THIS IS THE 4TH…”

Complaint filed with NHTSA · Transmission · January 12, 2018

“THE TIRE THREAD SHREDDED OFF OF BOTH SIDES OF THE WHEEL WHILE DRIVING, DAMAGING MUD FLAPS, ETC. 2015 JAYCO GREYHAWK RV (FORD 450 CHASIS). MILEAGE WAS ONLY 25000 MILES. OTHER TIRES APPEAR TO ALREAY DISPLAY SOFT SPOTS AND CRACKING - ESPECIALLY NEAR THE THREAD, VEHICLE IS GARAGE WHEN NOT IN USE.”

Complaint filed with NHTSA · Tires & Wheels · October 28, 2020

“TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS…”

Complaint filed with NHTSA · Fuel System · September 10, 2015

“TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS…”

Complaint filed with NHTSA · Engine · September 10, 2015

“The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not…”

Complaint filed with NHTSA · Suspension · October 29, 2021

2015 Ford E-450 — common questions

Is the 2015 Ford E-450 reliable?

The record is thin — 8 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 1 recall should be verified as completed.

Does the 2015 Ford E-450 have recalls?

Yes — NHTSA lists 1 recall campaign affecting the 2015 Ford E-450. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Is the 2015 Ford E-450 under NHTSA investigation?

NHTSA opened one investigation into this model year; all are now closed.

Which Ford E-450 years should you avoid?

Based on complaint rates and open investigations, the E-450 years to avoid are 1999, 2021, 2000, 2004, 2005. The cleanest record among E-450 years belongs to 2027.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.