Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 2 complaints on file for the 1996 GMC C25 — too few to judge reliability from owner reports alone — but 5 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
2
NHTSA complaints
5
Recalls
0
Investigations
1
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Brakes | 1 | 50% | — flat |
| Seats | 1 | 50% | — flat |
5 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
VEHICLE DESCRIPTION: EXTENDED CAB AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH RECLINING SEATS AND THE EASY-ENTRY FEATURE. THESE VEHICLES EXHIBIT A CONDITION IN WHICH A PINCH POINT EXISTS IN THE RECLINER MECHANISM THAT CAN TRAP AND PINCH A PERSON'S HAND OR FINGER(S) WHEN THE EASY-ENTRY FEATURE IS ACTIVATED.
Consequence
THIS PINCHING CAN CUT THE HAND OR POSSIBLY SEVER THE FINGER(S) WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL INSTALL A PROTECTOR COVER OVER THE RECLINER MECHANISM.
Defect
THE FOUR U-BOLTS NUTS ON EITHER SIDE OF THE REAR AXLE WERE UNDER-TORQUED.
Consequence
VEHICLE USAGE COULD CAUSE THE NUTS TO LOOSEN AND EVENTUALLY FALL OFF THE U-BOLT. THIS COULD RESULT IN SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy
DEALERS WILL CHECK THE U-BOLT NUT TORQUE AND RE-TORQUE ANY LOOSE U-BOLTS TO SPECIFICATION.
Defect
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence
CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy
DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Defect
THE SEAT RECLINER TO SEAT FRAME ATTACHING BOLTS ON THESE VEHICLES COULD LOOSEN, FATIGUE AND FRACTURE, ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.
Consequence
IF THIS WERE TO OCCUR TO THE DRIVER'S SEAT, THIS COULD RESULT IN A SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy
DEALERS WILL REMOVE ALL FOAM AND/OR FABRIC SANDWICHED BETWEEN THE RECLINER ASSEMBLY AND THE SEAT FRAME, INSTALL WASHERS BETWEEN THE SEAT RECLINER AND THE SEAT FRAME AT EACH ATTACHMENT POINT, AND INSTALL NEW ATTACHING BOLTS TORQUED TO A HIGHER SPECIFICATION. THESE CORRECTIONS WILL BE MADE TO BOTH THE DRIVER'S AND PASSENGER'S SEATS.
Defect
CERTAIN TRUCKS HAVE FUEL RAIL ASSEMBLIES WITH AN IMPROPERLY CRIMPED END RETAINER CLIP THAT RESULTS IN A FUEL LEAK.
Consequence
IF FUEL LEAKAGE OCCURS AND AN IGNITION SOURCE IS PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy
DEALERS WILL INSPECT THE FUEL RAIL ASSEMBLY AND REPLACE ANY FUEL RAIL ASSEMBLY WITH A JULIAN DATE CODE OF 95318 THROUGH 95338.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“CAUTION LIGHT; APPLIED PRESSURE TO PEDAL, HIT SMALL BUMP ABS DEACTIVATED, RESULTING IN REAR COLLISION. SECOND INSTANCE APPLIED HEAVY PRESSURE TO DERIVATIVE (PEDAL APPLICATION) LOUD SQUEAL DEVELOPED: FINALE: BRAKE LOCK UP.”
“RECALL # 97V-037000, VEHICLE BROUGHT TO DEALER ON THREE DIFFERENT TIMES. DEALER DOES NOT HAVE PARTS. PARTS WILL NOT BE AVAILABLE UNTIL MAY. *AK”
The record is thin — 2 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 5 recalls should be verified as completed.
Yes — NHTSA lists 5 recall campaigns affecting the 1996 GMC C25. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.