VehicleVerdict

2005 International 7600 problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just one complaint on file for the 2005 International 7600 — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

1

NHTSA complaints

3

Recalls

0

Investigations

0

Crash-involved

1

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 2005 compare to other 7600 years?

7600 NHTSA complaints by model year, 2005 highlighted1 complaints2002: 0 complaints2003: 0 complaints2004: 0 complaints2005: 1 complaints2006: 0 complaints2007: 0 complaints2008: 0 complaints2009: 0 complaints2010: 0 complaints2011: 0 complaints2016: 0 complaints
7600 NHTSA complaints by model year, 2005 highlighted. Red bars are years to avoid.

See all 7600 years to avoid →

What are the most common 2005 International 7600 problems?

ComponentComplaintsShare
Engine1100%

Does the 2005 International 7600 have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

05V567000EngineDecember 21, 2005 · 6,848 units

Defect

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE ENGINE ELECTRICAL GROUND CABLE THAT CONNECTS THE ENGINE BLOCK WITH THE STARTER MAY BE ROUTED IN A WAY THAT COULD CAUSE CHAFING AGAINST THE STARTER'S POSITIVE BATTERY CABLES.

Consequence

IF CHAFING OCCURS BETWEEN THE POSITIVE AND NEGATIVE CABLES, AN ELECTRICAL SHORT MAY RESULT AND MAY CAUSE A VEHICLE FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Remedy

DEALERS WILL INSPECT THE ENGINE GROUND CABLES FOR PROPER ROUTING. IF ANY CHAFING IS FOUND, THE ENGINE BLOCK GROUND CABLE WILL BE REPLACED WITH A SHORTER (280MM) CABLE AND ANY OTHER DAMAGED CABLES WILL BE REPLACED AND ROUTED CORRECTLY FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

05V188000Trailer HitchApril 28, 2005 · 4,616 units

Defect

ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.

Consequence

IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

Remedy

DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

04V569000Body & StructureDecember 3, 2004 · 17,443 units

Defect

ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT.

Consequence

THESE BOLTS CAN LOOSEN DURING NORMAL VEHICLE USE AND FALL OUT. THIS MAY LEAD TO THE CAB SEPARATING FROM THE VEHICLE'S CHASSIS DURING A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Remedy

AS AN INTERIM ACTION, DEALERS WILL PROPERLY TIGHTEN THE EXISTING CAB MOUNTING BOLTS AND REPLACE ANY MISSING BOLTS. AS SOON AS PARTS ARE AVAILABLE, DEALERS WILL REPLACE ALL SIXTEEN BOLTS AND TIGHTEN THEM PROPERLY. AN INTERIM LETTER WAS SENT TO OWNERS ON FEBRUARY 11, 2005. ANOTHER LETTER WAS SENT TO OWNERS ON APRIL 8, 2005, AS SOON AS PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“TRUCK WAS PARKED ON SATURDAY SURVEILLANCE CAMERA SHOWS WHAT APPEARS TO BE SPARKING UNDER VEHICLE SUNDAY EVENING WHICH CAUSED FIRE... BURNED ENTIRE TRUCK AND TRUCK PARKED NEXT TO IT. ALL ON VIDEO SURVEILLANCE. *TR”

Complaint filed with NHTSA · Engine · March 30, 2014 · fire

2005 International 7600 — common questions

Is the 2005 International 7600 reliable?

The record is thin — 1 NHTSA complaint — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.

Does the 2005 International 7600 have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2005 International 7600. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.