Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just one complaint on file for the 2006 International Cf500 — too few to judge reliability from owner reports alone — but 3 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
1
NHTSA complaints
3
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Electrical System | 1 | 100% | new |
3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
ON CERTAIN TRUCKS, THE A-PILLAR MOUNTED ENTRY/EGRESS GRAB HANDLE MAY LOOSEN AND POSSIBLY SEPARATE FROM THE VEHICLE.
Consequence
THIS SEPARATION CAN OCCUR WITHOUT WARNING AND POSSIBLY CONTRIBUTE TO PERSONAL INJURY.
Remedy
DEALERS WILL REPLACE THE CAB ENTRY/EGRESS GRAB HANDLE. THE RECALL BEGAN ON FEBRUARY 16, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
Defect
ON CERTAIN TRUCKS EQUIPPED WITH VT-275 ENGINES, THE ELECTRICAL CONNECTOR OF THE INJECTION PRESSURE REGULATOR (IPR) VALVE ON THE ENGINE CAN FILL WITH RAIN WATER AND ROAD DEBRIS, POSSIBLY CAUSING TERMINAL CORROSION THAT MAY LEAD TO ELECTRICAL VOLTAGE DROPS.
Consequence
IF THIS OCCURS, ERRATIC BEHAVIOR OF THE IPR VALVE CAN CAUSE THE ENGINE TO SHUT DOWN WITHOUT WARNING WHILE THE VEHICLE IS IN OPERATION. IF AN ENGINE SHUTDOWN OCCURS, THE VEHICLE MAY BECOME STRANDED ON A ROADWAY. THIS MAY LEAD TO PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy
DEALERS WILL INSPECT FOR CORROSION AND IF A SIGNIFICANT AMOUNT IS PRESENT, THE CONNECTOR WILL BE REMOVED AND A NEW, SEALED CONNECTOR INSTALLED. IF NO CORROSION IS PRESENT, THE CONNECTOR WILL BE CLEANED, FILLED WITH DIELECTRIC GREASE AND COVERED WITH A PROTECTIVE WRAP THAT WILL PREVENT FUTURE CORROSION OF THE CONNECTOR TERMINALS. THE RECALL BEGAN ON NOVEMBER 9, 2006. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
Defect
ON CERTAIN TRUCKS, THE CAB ENTRY STEPS WERE MANUFACTURED INCORRECTLY CAUSING THEM TO HAVE LOWER MATERIAL STRENGTH PROPERTIES THAN DESIGNED. THESE LOWER MATERIAL STRENGTH PROPERTIES CAN ALLOW THE STEP TREAD TO FRACTURE AND SEPARATE FROM THE VEHICLE UNDER NORMAL USAGE.
Consequence
STEP TREAD SEPARATION WHILE A PERSON IS ENTERING OR EXITING THE CAB, MAY RESULT IN PROPERLY DAMAGE OR PERSONAL INJURY.
Remedy
DEALERS WILL INSTALL REINFORCED METAL BRACKETS ON BOTH CAB ENTRY STEP PLATFORMS. THE RECALL BEGAN ON DECEMBER 2, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“DT*: THE CONTACT STATED WHEN RECALL LETTER # 06V378000 FOR THE ELECTRICAL SYSTEM WAS RECEIVED; AN APPOINTMENT WAS SCHEDULED WITH A SERVICE DEALER. TWO WEEKS LATER, THE VEHICLE HAD STILL NOT BEEN REPAIRED DUE TO UNAVAILABLE PARTS. IT HAS BEEN A MONTH SINCE THE PARTS WERE REQUESTED BY THE CONTACT.…”
The record is thin — 1 NHTSA complaint — so owner-report data can't strongly confirm reliability either way, though 3 recalls should be verified as completed.
Yes — NHTSA lists 3 recall campaigns affecting the 2006 International Cf500. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.