Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 0 complaints on file for the 1998 Navistar 9200 — too few to judge reliability from owner reports alone — but 5 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.
0
NHTSA complaints
5
Recalls
1
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
5 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.
Defect
VEHICLE DESCRIPTION: TRUCKS ASSEMBLED WITH SKF LEVEL 2 TRUCK HUB UNITS (THU) RECEIVED FROM MERITOR. THESE HUBS CAN FATIGUE CRACK.
Consequence
THIS FATIGUE CRACKING CAN RESULT IN WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THESE HUBS WITH PRODUCTION LEVEL 3 HUBS.
Defect
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCK CHASSIS EQUIPPED WITH 16,000 LB., 18,000 LB., OR 20,000 LB. HEAVY DUTY STEERING AXLES. THE INNER WHEEL BEARING CONE FOR THE STEERING AXLE WHEEL HUB ASSEMBLY DOES NOT PROPERLY FIT ONTO THE NAVISTAR STEERING AXLE SPINDLE ASSEMBLY. IMPROPER FIT OF THE BEARING TO THE SPINDLE INCREASES THE STRESS LEVELS TO THE STEERING AXLE SPINDLE WHICH COULD CAUSE SPINDLE FAILURE.
Consequence
IF THE SPINDLE FAILS, A LOSS OF DRIVER CONTROL COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy
DEALERS WILL REMOVE THE LEFT AND RIGHT HUB/DRUM ASSEMBLIES FROM THE STEERING AXLES AND REPLACE THE INNER WHEEL BEARING CONES AND CUPS.
Defect
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH SPICER SPL170 55MM CENTER BERING PACKAGE. THE END YOKE RETAINING NUT CAN LOOSEN.
Consequence
IF THIS CONDITION OCCURS, THE DRIVE LINE CAN VIBRATE AND SEPARATE FROM THE VEHICLE, CAUSING VEHICULAR DAMAGE, OR PERSONAL INJURY, OR BOTH.
Remedy
DEALERS WILL REMOVE THE 55MM CENTER BEARING PACKAGE AND COUPLER SHAFT, AND REPLACE IT WITH A NEW COUPLER SHAFT AND A 60MM CENTER BEARING PACKAGE. AN INTERIM REMEDY CAN BE IMPLEMENTED BY PLACING A SPOT WELD ON THE COUPLING SHAFT THREADS UNTIL PARTS ARE AVAILABLE.
Defect
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH PROSLEEPER BUNKS. A MICRO RELAY LOCATED BEHIND THE HVAC CONTROL PANEL IN THE BUNK CAN CORRODE FROM MOISTURE.
Consequence
THIS CONDITION CAN RESULT IN A SHORT CIRCUIT BETWEEN CONTACTS ON THE RELAY INCREASING THE RISK OF A VEHICLE FIRE.
Remedy
DEALERS WILL REMOVE THE EXISTING RELAY AND REPLACE IT WITH A SEALED RELAY.
Defect
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR C-10 OR C-12 ENGINES. A BRACKET OR P-CLAMP AT THE REAR OF THE ENGINE THAT SUPPORTS THE COMPRESSOR DISCHARGE LINE WAS OMITTED.
Consequence
IF THE COMPRESSOR DISCHARGE LINE FAILS, THE AIR SYSTEM COULD BE DEPLETED AND CAUSE THE PARKING BRAKES TO APPLY. THIS CONDITION CAN CAUSE THE VEHICLE TO SLOW DOWN OR STOP UNEXPECTEDLY, CAUSING A VEHICLE CRASH WHICH COULD RESULT IN PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Remedy
DEALERS WILL INSTALL P-CLAMPS AND A BRACKET AT THE REAR OF THE ENGINE.
The record is thin — 0 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 5 recalls should be verified as completed.
Yes — NHTSA lists 5 recall campaigns affecting the 1998 Navistar 9200. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
NHTSA opened one investigation into this model year; all are now closed.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.