VehicleVerdict

2006 Workhorse W20 problems

Verdict · NHTSA data

Limited data — recalls on file

NHTSA has just 3 complaints on file for the 2006 Workhorse W20 — too few to judge reliability from owner reports alone — but 2 recall campaigns apply to this year, so any used example should have its VIN checked for completed recall work.

3

NHTSA complaints

2

Recalls

0

Investigations

0

Crash-involved

0

Fires reported

0

Injuries

0

Deaths

—

NCAP overall

How does 2006 compare to other W20 years?

W20 NHTSA complaints by model year, 2006 highlighted12 complaints2000: 1 complaints2001: 2 complaints2002: 6 complaints2003: 12 complaints2004: 11 complaints2005: 3 complaints2006: 3 complaints2007: 0 complaints2008: 0 complaints
W20 NHTSA complaints by model year, 2006 highlighted. Red bars are years to avoid.

See all W20 years to avoid →

What are the most common 2006 Workhorse W20 problems?

ComponentComplaintsShare
Brakes267%
Steering133%

Does the 2006 Workhorse W20 have recalls?

2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

09V110000BrakesApril 3, 2009 · 48,876 units

Defect

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence

THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy

WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

06V148000SteeringMay 2, 2006 · 3,881 units

Defect

CERTAIN CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

Consequence

THIS STEERING CONDITION COULD INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS. THE RECALL BEGAN ON MAY 22, 2006. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“TL*THE CONTACT OWNS A 2006 MONACO COACH MONARCH SE RV EQUIPPED WITH A WORKHORSE W20 CHASSIS. THE CONTACT REFERENCED RECALL 09V110000 (SERVICE BRAKES, HYDRAULIC) AND STATED THAT THE RECALL REPAIR WAS PERFORMED ON OCTOBER 26, 2010. THE DEALER RETURNED THE VEHICLE WITH THE LEFT FRONT ROTOR CRACKED AND…”

Complaint filed with NHTSA · Brakes · October 26, 2010

“THE STEERING ON MY 2007/2006 WORKHORSE W-20 CHASSIS IS EXTREMELY/DANGEROUSLY LOOSE IN THAT IT IS VERY DIFFICULT TO DRIVE SAFELY DURING MINIMAL ENVIRONMENTAL CONDITIONS OF WINDS AND PASSING VEHICLES. I COMPARE THIS VEHICLE TO THREE OTHER MOTORHOMES WITH WORKHORSE CHASSIS AND 110,000 + MILES OF…”

Complaint filed with NHTSA · Steering · July 31, 2006

2006 Workhorse W20 — common questions

Is the 2006 Workhorse W20 reliable?

The record is thin — 3 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 2 recalls should be verified as completed.

Does the 2006 Workhorse W20 have recalls?

Yes — NHTSA lists 2 recall campaigns affecting the 2006 Workhorse W20. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.