VehicleVerdict

2006 Chevrolet Aveo problems

Verdict · NHTSA data

A typical year for this model

The 2006 Chevrolet Aveo sits mid-pack among Aveo years: 280 NHTSA complaints against a model median of roughly 272, with a single recall and no defect investigations. Complainants reported 11 injuries in total across these filings.

Electrical System leads the complaint categories with 71 reports (25% of the total).

280

NHTSA complaints

1

Recalls

0

Investigations

23

Crash-involved

24

Fires reported

11

Injuries

0

Deaths

—

NCAP overall

How does 2006 compare to other Aveo years?

Aveo NHTSA complaints by model year, 2006 highlighted323 complaints2004: 271 complaints2005: 323 complaints2006: 280 complaints2007: 307 complaints2008: 251 complaints2009: 278 complaints2010: 105 complaints2011: 112 complaints2012: 3 complaints
Aveo NHTSA complaints by model year, 2006 highlighted. Red bars are years to avoid.

See all Aveo years to avoid →

What are the most common 2006 Chevrolet Aveo problems?

ComponentComplaintsShare
Electrical System7125%
Airbags5821%
Lighting3914%
Engine238%
Transmission166%
Suspension124%
Speed Control114%
Brakes104%
Steering93%
Body & Structure83%
Other73%
Fuel System41%
Tires & Wheels41%
Seat Belts31%
Latches & Locks31%
Visibility & Wipers21%

Does the 2006 Chevrolet Aveo have recalls?

1 NHTSA recall campaign on file. Recall repairs are free at franchised dealers.

14V261000LightingMay 19, 2014 · 218,000 units

Defect

General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

Consequence

If the DRL module melts due to the heat generation, it could cause a vehicle fire.

Remedy

GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“SO I WAS AT HOME AND MY CAR WAS PARKED OUTSIDE AND IT CAUGHT ON FIRE IN THE INSIDE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. IT DAMAGED THE DASHBOARD AND THE WINDOW. I HAVE READ THAT IT IS A RECALL ON MY VEHICLE WHICH CAUSES IT TO CATCH ON FIRE. MANUFACTURER RECALL NUMBERA140093 NHTSA RECALL…”

Complaint filed with NHTSA · Electrical System · May 27, 2019 · fire

“SO I WAS AT HOME AND MY CAR WAS PARKED OUTSIDE AND IT CAUGHT ON FIRE IN THE INSIDE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. IT DAMAGED THE DASHBOARD AND THE WINDOW. I HAVE READ THAT IT IS A RECALL ON MY VEHICLE WHICH CAUSES IT TO CATCH ON FIRE. MANUFACTURER RECALL NUMBERA140093 NHTSA RECALL…”

Complaint filed with NHTSA · Airbags · May 27, 2019 · fire

“TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 70 MPH, SMOKE ENTERED THE VEHICLE THROUGH THE VENTS AND IMPAIRED THE CONTACT'S VISIBILITY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR…”

Complaint filed with NHTSA · Lighting · August 14, 2015 · fire

“TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 70 MPH, SMOKE ENTERED THE VEHICLE THROUGH THE VENTS AND IMPAIRED THE CONTACT'S VISIBILITY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR…”

Complaint filed with NHTSA · Engine · August 14, 2015 · fire

“TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT SHE COULD NOT REMOVE THE KEY FROM THE IGNITION. IN ADDITION, THE VEHICLE WOULD NOT PROPERLY ACCELERATE ON AN INCLINE. THE VEHICLE WAS TAKEN FOR INSPECTION HOWEVER, THE MECHANIC COULD NOT DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT…”

Complaint filed with NHTSA · Transmission · July 7, 2010

2006 Chevrolet Aveo — common questions

Is the 2006 Chevrolet Aveo reliable?

It is close to typical for the Aveo: 280 NHTSA complaints, 1 recall, and no investigations on file.

What are the most common 2006 Aveo problems?

According to NHTSA complaint data, the leading problem areas are electrical system (71 complaints), airbags (58 complaints), lighting (39 complaints).

Does the 2006 Chevrolet Aveo have recalls?

Yes — NHTSA lists 1 recall campaign affecting the 2006 Chevrolet Aveo. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.