VehicleVerdict

2007 Chevrolet Aveo problems

Verdict · NHTSA data

A typical year for this model

The 2007 Chevrolet Aveo sits mid-pack among Aveo years: 307 NHTSA complaints against a model median of roughly 272, with 2 recalls and no defect investigations. Reports tied to this model year include 3 deaths and 35 injuries, per the complaint records themselves.

Airbags leads the complaint categories with 84 reports (27% of the total).

307

NHTSA complaints

2

Recalls

0

Investigations

35

Crash-involved

24

Fires reported

35

Injuries

3

Deaths

—

NCAP overall

How does 2007 compare to other Aveo years?

Aveo NHTSA complaints by model year, 2007 highlighted323 complaints2004: 271 complaints2005: 323 complaints2006: 280 complaints2007: 307 complaints2008: 251 complaints2009: 278 complaints2010: 105 complaints2011: 112 complaints2012: 3 complaints
Aveo NHTSA complaints by model year, 2007 highlighted. Red bars are years to avoid.

See all Aveo years to avoid →

What are the most common 2007 Chevrolet Aveo problems?

ComponentComplaintsShare
Airbags8427%
Electrical System5317%
Lighting3210%
Engine3010%
Brakes186%
Transmission145%
Suspension114%
Speed Control103%
Steering103%
Other83%
Fuel System83%
Body & Structure83%
Tires & Wheels72%
Visibility & Wipers62%
Seat Belts41%
Seats31%
Latches & Locks10%

Does the 2007 Chevrolet Aveo have recalls?

2 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

14V261000LightingMay 19, 2014 · 218,000 units

Defect

General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

Consequence

If the DRL module melts due to the heat generation, it could cause a vehicle fire.

Remedy

GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

06V398000Fuel SystemOctober 17, 2006 · 17,676 units

Defect

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.

Consequence

IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.

Remedy

DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“TL*THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CURRENT AND FAILURE MILEAGES WERE 6,000. WHILE DRIVING 35MPH, HER DAUGHTER CRASHED INTO A TELEPHONE POLE. THE VEHICLE WAS DAMAGED. THE SIDE AND FRONT AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES. THE PURCHASE DATE IS NOT AVAILABLE. A POLICE…”

Complaint filed with NHTSA · Airbags · December 27, 2007 · crash

“DAYLIGHT BULB FUSED AND ELECTRICAL DASHBOARD INSTRUMENTS STOPPED WORKING. IGNITION KEY GOT STUCK AND THE GEAR CHANGING STICK WOULD NOT GET OUT OF PARKING GEAR. THERE WAS A FAINT BURNING SMELL. SIMILAR INCIDENCE HAS HAPPENED MULTIPLE TIMES, EVERYTIME. WITHIN 2 WEEKS OF REPAIR. *TR”

Complaint filed with NHTSA · Electrical System · January 1, 2013 · fire

“DAYLIGHT BULB FUSED AND ELECTRICAL DASHBOARD INSTRUMENTS STOPPED WORKING. IGNITION KEY GOT STUCK AND THE GEAR CHANGING STICK WOULD NOT GET OUT OF PARKING GEAR. THERE WAS A FAINT BURNING SMELL. SIMILAR INCIDENCE HAS HAPPENED MULTIPLE TIMES, EVERYTIME. WITHIN 2 WEEKS OF REPAIR. *TR”

Complaint filed with NHTSA · Lighting · January 1, 2013 · fire

“I WAS DRIVING TO MY MOTHER'S HOUSE, THE CAR WAS NOT SHIFTING RIGHT AND THE ENGINE WAS WHINING, ALL OF A SUDDEN I SMELLED SMOKE AND SEEN FIRE UNDER THE HOOD. GM WOULD ONLY FIX THE HARNESS , THE VEHICLE WOULD START AGAIN BUT YOU COULD NOT DRIVE IT. NO POWER IN THE ENGINE. SO I HAD TO EAT $6400.00…”

Complaint filed with NHTSA · Engine · October 10, 2014 · fire

“TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. SHE STATED THAT WHILE APPROACHING A STOP LIGHT SHE APPLIED PRESSURE TO THE BRAKE PEDAL, BUT THE VEHICLE WOULD NOT STOP. AS A CONSEQUENCE, SHE CRASHED INTO ANOTHER VEHICLE. THE VEHICLE WAS COMPLETELY DESTROYED. A POLICE REPORT WAS FILED. THE CAUSE OF THE…”

Complaint filed with NHTSA · Brakes · August 28, 2009 · crash

2007 Chevrolet Aveo — common questions

Is the 2007 Chevrolet Aveo reliable?

It is close to typical for the Aveo: 307 NHTSA complaints, 2 recalls, and no investigations on file.

What are the most common 2007 Aveo problems?

According to NHTSA complaint data, the leading problem areas are airbags (84 complaints), electrical system (53 complaints), lighting (32 complaints).

Does the 2007 Chevrolet Aveo have recalls?

Yes — NHTSA lists 2 recall campaigns affecting the 2007 Chevrolet Aveo. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.