Verdict · NHTSA data
Limited data — recalls on file
NHTSA has just 2 complaints on file for the 1998 Chevrolet G20 — too few to judge reliability from owner reports alone — but one recall campaign applies to this year, so any used example should have its VIN checked for completed recall work.
2
NHTSA complaints
1
Recalls
0
Investigations
0
Crash-involved
0
Fires reported
0
Injuries
0
Deaths
—
NCAP overall
| Component | Complaints | Share | vs prior year |
|---|---|---|---|
| Electrical System | 1 | 50% | ▼ down |
| Body & Structure | 1 | 50% | ▼ down |
1 NHTSA recall campaign on file. Recall repairs are free at franchised dealers.
Defect
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence
IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Remedy
DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.
“THIS IS THE FIFTH OR MORE TIME I HAVE BEEN DRIVING MY VEHICLE AT LOW OR HIGH SPEED AND THE ENGINE COMPLETELY QUITS WITHOUT WARNING CAUSING ME TO PULL OFF THE FREE WAY TODAY TO AVOID A CATASTROPHIC ACCIDENT. MY VAN GOES COMPLETELY DEAD FROM 70 MPH. THE DEALER INSTALLED ALARM WAS TRIGGERED AND HAD TO…”
The record is thin — 2 NHTSA complaints — so owner-report data can't strongly confirm reliability either way, though 1 recall should be verified as completed.
Yes — NHTSA lists 1 recall campaign affecting the 1998 Chevrolet G20. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.
Based on complaint rates and open investigations, the G20 years to avoid are 1995, 1993, 1994. The cleanest record among G20 years belongs to 1981.
Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.
Compiled by Sharon Ben-Moshe, Founder.