VehicleVerdict

2007 Ford F-250 Sd problems

Verdict · NHTSA data

One of the years to avoid

With 85 complaints filed to NHTSA — about 2.4 times the median F-250 Sd year — the 2007 model ranks #13 of 36 F-250 Sd years for complaint volume. It lands on the years-to-avoid list.

Suspension leads the complaint categories with 31 reports (37% of the total).

85

NHTSA complaints

3

Recalls

2

Investigations

2

Crash-involved

1

Fires reported

4

Injuries

0

Deaths

—

NCAP overall

How does 2007 compare to other F-250 Sd years?

F-250 Sd NHTSA complaints by model year, 2007 highlighted381 complaints1991: 1 complaints1992: 3 complaints1993: 4 complaints1994: 2 complaints1995: 12 complaints1996: 11 complaints1997: 52 complaints1998: 1 complaints1999: 304 complaints2000: 277 complaints2001: 331 complaints2002: 282 complaints2003: 229 complaints2004: 345 complaints2005: 381 complaints2006: 353 complaints2007: 85 complaints2008: 175 complaints2009: 33 complaints2010: 48 complaints2011: 189 complaints2012: 97 complaints2013: 32 complaints2014: 37 complaints2015: 31 complaints2016: 15 complaints2017: 119 complaints2018: 23 complaints2019: 13 complaints2020: 4 complaints2021: 0 complaints2022: 5 complaints2023: 76 complaints2024: 52 complaints2025: 19 complaints2026: 13 complaints
F-250 Sd NHTSA complaints by model year, 2007 highlighted. Red bars are years to avoid.

See all F-250 Sd years to avoid →

What are the most common 2007 Ford F-250 Sd problems?

ComponentComplaintsShare
Suspension3136%
Steering2327%
Tires & Wheels78%
Engine56%
Body & Structure34%
Transmission34%
Other34%
Seat Belts22%
Brakes22%
Fuel System22%
Airbags22%
Speed Control11%
Electrical System11%

Does the 2007 Ford F-250 Sd have recalls?

3 NHTSA recall campaigns on file. Recall repairs are free at franchised dealers.

20E090000OtherDecember 9, 2020 · 102 units

Defect

Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.

Consequence

If the steering locks, it can increase the risk of a crash.

Remedy

Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

11V352000LightingJuly 13, 2011 · 26,715 units

Defect

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Consequence

NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

08E026000OtherMarch 27, 2008 · 338 units

Defect

TRUXXX IS RECALLING 338 AFTERMARKET REPLACEMENT WELDED 3" LIFT BLOCKS FOR REAR SUSPENSIONS, PART NO. 206073, INCLUDED IN SUSPENSION KIT NOS. 108035 AND 108036, SOLD BETWEEN JULY 26, 2007 AND MARCH 4, 2008, FOR USE ON FORD MY 2005-2008 F-250 SUPERDUTY 4X4 LIGHT TRUCKS. COMPRESSIVE FORCES OF THE WELDED LIFT BLOCKS RESULTING FROM FORESEEABLE AND EXCESS VEHICLE PAYLOADS AS WELL AS OVER-TIGHTENING OF THE U-BOLTS DURING INSTALLATION MAY DISTORT THE BLOCKS, REDUCING THE INTENDED CLAMPING FORCE OF THE U-BOLTS.

Consequence

THIS COULD ALLOW POSSIBLE SHIFTING AND DAMAGE TO THE REAR DRIVE SHAFT AND AXLE.

Remedy

TRUXXX WILL NOTIFY CUSTOMERS/INSTALLERS AND WILL REPLACE AFFECTED WELDED LIFT BLOCKS WITH EITHER NON-WELDED ALUMINUM OR CAST IRON BLOCKS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 16, 2008. OWNERS MAY CONTACT TRUXXX AT 1-800-381-8320.

Consumer complaints filed with NHTSA

Representative excerpts, cleaned of personal information. These are consumer statements, not verified defects.

“PICKED UP MY F250 SUPER DUTY FROM THE SERVICE AT THE FORD DEALER, DRIVING IT ON THE FREEWAY OVERPASS, HIT A BUMP ON THE OVER PASS AND MY FRONT END STARTED SHAKING VIOLENTLY. I HAD NO CONTROL, I HAD TO STOP ON THE FREEWAY TO MAKE IT STOP SHAKING, ALMOST CAUSED A PILE UP. CALLED THE DEALER AND THEY…”

Complaint filed with NHTSA · Suspension · June 17, 2011

“TL* THE CONTACT OWNS A 2007 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHAKE VIOLENTLY AS THE CONTACT TRAVELED OVER AN UNEVEN ROAD SURFACE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT…”

Complaint filed with NHTSA · Steering · December 15, 2009

“WE HAVE 3 OUT OF 4 TIRES SEPARATE WITH THE TREAD COMING COMPLETELY OFF OF ONE OF THE TIRES CAUSING MAJOR DAMAGE TO BED AND NUMBER OF OUR TRUCK. THE FIRST TIRE WAS WITH IN A COUPLE OF MONTHS OF PURCHASE. THE OTHER 2 TIRES HAPPEN WITH IN 30 MINUTES OF EACH OTHER. ALL UNDER 10,000 MILES OF USE. YOUR…”

Complaint filed with NHTSA · Tires & Wheels · February 14, 2014

“THE VEHICLE LACKS ACCELERATION FROM A STANDING STOP, WHEN YOU TRY TO MERGE INTO TRAFFIC THE VEHICLE HESITATES AND WILL NOT MOVE FOR A 2 TO 3 SECOND SPAN CAUSING VEHICLES ON THE HIGHWAY TO CLOSE ON THE VEHICLE. ON TWO OCCASIONS I HAD TO SWERVE OFF THE ROAD TO AVOID A COLLISION. *JB”

Complaint filed with NHTSA · Engine · August 20, 2007

“THE VEHICLE LACKS ACCELERATION FROM A STANDING STOP, WHEN YOU TRY TO MERGE INTO TRAFFIC THE VEHICLE HESITATES AND WILL NOT MOVE FOR A 2 TO 3 SECOND SPAN CAUSING VEHICLES ON THE HIGHWAY TO CLOSE ON THE VEHICLE. ON TWO OCCASIONS I HAD TO SWERVE OFF THE ROAD TO AVOID A COLLISION. *JB”

Complaint filed with NHTSA · Transmission · August 20, 2007

2007 Ford F-250 Sd — common questions

Is the 2007 Ford F-250 Sd reliable?

NHTSA data argues against it: 85 complaints put the 2007 model at #13 of 36 F-250 Sd years. It is one of the F-250 Sd years to avoid.

What are the most common 2007 F-250 Sd problems?

According to NHTSA complaint data, the leading problem areas are suspension (31 complaints), steering (23 complaints), tires & wheels (7 complaints).

Does the 2007 Ford F-250 Sd have recalls?

Yes — NHTSA lists 3 recall campaigns affecting the 2007 Ford F-250 Sd. Recall repairs are free at franchised dealers; check the VIN at nhtsa.gov/recalls to confirm the work was done.

Is the 2007 Ford F-250 Sd under NHTSA investigation?

NHTSA opened 2 investigations into this model year; all are now closed.

Which Ford F-250 Sd years should you avoid?

Based on complaint rates and open investigations, the F-250 Sd years to avoid are 2005, 2006, 2004, 2001, 1999, 2002, 2000, 2003, 2011, 2008, 2017, 2012, 2007, 2023, 2015, 2018, 2016, 2019, 2020, 2021. The cleanest record among F-250 Sd years belongs to 1998.

Related

Based on NHTSA ODI data through June 2026. Complaints are consumer-reported and unverified. Updated July 5, 2026.

Compiled by Sharon Ben-Moshe, Founder.